36
pewag levo hook LH
EN
9.3 Exchanging the safety catch set
If parts of the safety catch set are missing or defect,
(e.g. broken spring), you may replace them as follows:
Fold the safety catch
1
down fully towards the inner part of the
swivel hook and loosen the safety screw
2
using an Allen key
as shown in fig. 15. Slide out the axle.
3
You can now pull the
safety catch
1
incl. spring
4
out of the hook (fig. 16). Remove
the spring.
When assembling the set, follow these steps in reverse order,
paying particular attention to the following points:
• When inserting the spring
4
in the safety latch
1
, the
spring leg running parallel to the axial direction
5
must be
inserted into the drill hole on the inside of the safety latch
(fig. 17).
• The other spring leg, i.e. the one running transversal to the
axial direction
6
, must be inserted in the drill hole
7
in the
hook (fig. 18).
• Use a small amount of threadlock for the safety screw
2
(e.g. Loctite type 243)
After assembly, always check that the safety catch is movable
and springs back into a vertical position on its own accord from
both directions. If this is not the case, it is likely that spring leg
6
was not inserted into the hook drill hole
7
. Take the safety
catch to pieces and re-assemble correctly
9.4 Exchanging the safety catch
counter piece
To exchange the safety catch counter piece,
remove both screws
1
with a torx wrench (size TX 30) and pull
off the counter piece
2
(fig. 19). To re-fit the counter piece,
follow these steps in reverse order. Use a small amount of
medium-strength threadlock for the screws (e.g. Loctite type
243) Always check whether the safety catch rests properly on
the support of the counter piece.
1
2
3
Fig. 15
4
Fig. 16
7
5
6
Fig. 17
Fig. 18
1
2
Fig. 19
Summary of Contents for levo hook LH Series
