TABLE III-I INSPECTION REPORT (cont)
Nature of Inspection
B. ENGINE GROUP (CONTINENTAL) (Cont.)
7. Clean and inspect oil radiator cooling fins. Verify that there is no radiator
damage......................................................................................................................
O
O
O
8. Fill engine oil sump with oil per approved information cowl, or lubrication
O
O
O
-CAUTION-
DO NOT USE MULTIGRADE OIL until Hartzell
Service Bulletin 142B has been complied with.
-CAUTION-
Prior to cleaning engine, use caution not to
contaminate vacuum pump with cleaning fluid. Cap
all openings.
O
O
O
O
10.Inspect condition of spark plugs. (Clean and adjust gap as required)
O
O
O
11.Check cylinder compression, preferably with engine warm. (Read Note 12)..........
12.Inspect ignition harness and insulators (high tension leakage and continuity)
(Read Notes 5 and 21) ..............................................................................................
O
O
O
13.Check magneto points for proper clearance (maintain clearance of 0.018 +/-
O
O
O
14.Inspect magneto or oil seal leakage..........................................................................
O
O
O
15.Inspect breaker felts for proper lubrication...............................................................
O
O
O
16.Inspect distributor block for cracks, burned areas, or corrosion, and height of
contact springs ..........................................................................................................
O
O
17.Check magneto-to-engine timing (Read Note 15)....................................................
O
O
O
O
19.Remove induction air filter and tap gently to remove all foreign particles
(replace as required)..................................................................................................
O
O
O
O
20.Clean injector nozzles (Clean with acetone only) ...................................................
O
O
O
O
21.Inspect induction airbox valve operation and check for excessive wear or..............
O
O
O
cracks; replace defective parts..................................................................................
O
O
O
22.Inspect fuel injector attachments for loose hardware ..............................................
O
O
O
23.Inspect intake seals for leaks and clamps for tightness (Read Note 24)...................
O
O
O
24.Inspect all air inlet duct hoses (Replace as required)................................................
O
O
O
25.Inspect condition of flexible fuel lines. (Replace all outdated or deteriorated
hoses)........................................................................................................................
O
O
O
O
27.Clean gascolator bowl and screen.............................................................................
O
O
O
O
28.Inspect fuel system for leaks ....................................................................................
O
O
O
50
500
1000
100
Inspection Time (HRS)
CHEROKEE ARROW III SERVICE MANUAL
1D5
Revised 2/13/89
INSPECTION
Summary of Contents for ARROW III
