TABLE III-I INSPECTION REPORT (cont)
Nature of Inspection
B. ENGINE GROUP (CONTINENTAL) (cont.)
29.Inspect condition and operation of fuel pumps (engine driven and electric) ...........
O
O
O
30.Overhaul or replace engine-driven fuel pumps per manufacturer’s
recommendations (Read Note 5) ..............................................................................
31.Overhaul or replace electric fuel pump as required .................................................
O
32.Inspect hoses, wires, clamps, condition, and operation of vacuum pump(s)
(engine-driven and auxiliary electrically-driven) (Read Note 25) ...........................
O
O
O
33.Replace engine or electrically driven vacuum pump(s) (Read Note(s) 5 and 25)....
O
34.Inspect throttle, alternate air, mixture, and propeller controls for security, travel,
and operating condition ............................................................................................
O
O
O
35.Inspect exhaust stacks, connections, and gaskets (Replace gaskets as required) ....
O
O
O
O
36.Inspect breather tubes for obstructions and security.................................................
O
O
O
37.Inspect crankcase for cracks, leaks, and security of seam bolts...............................
O
O
O
38.Inspect engine mounts for cracks and loose ............................................................
O
O
O
39.Inspect rubber engine mount bushings for deterioration (replace as reqd.) or at
engine overhaul ........................................................................................................
O
O
O
40.Inspect all engine baffles and seals...........................................................................
O
O
O
41.Inspect fire wall seals................................................................................................
O
O
O
42.Inspect condition of alternator and starter ................................................................
O
O
O
43.Inspect all lines, hoses, air ducts, electrical leads, and engine attachments for
security, proper routing, chafing, cracks, deterioration and correct installation
(Refer to latest Piper Service Bulletin 561)..............................................................
O
O
O
O
44.Check air conditioner compressor oil level (Read Note 13).....................................
O
O
O
45.Inspect condition and tension of compressor drive belt (Refer to Service
O
O
O
46.Inspect security of compressor mounting.................................................................
O
O
O
47.Inspect compressor clutch security, wiring, and condition.......................................
O
O
O
48.Check fluid in brake reservoir (Fill as required) ......................................................
O
O
O
O
49.Overhaul or replace propeller governor per manufacturer’s recommendations.
(Refer to latest revision of Hartzell Letter 61)..........................................................
50
500
1000
100
Inspection Time (HRS)
CHEROKEE ARROW III SERVICE MANUAL
1D6
Revised 2/13/89
INSPECTION
Summary of Contents for ARROW III
