TABLE III-I INSPECTION REPORT (cont)
Nature of Inspection
D. ENGINE GROUP (LYCOMING) (cont.)
48.Inspect condition and tension of alternator drive belt (Refer to Service Manual,
Section XI; XIV, if air conditioner is installed .......................................................
O
O
O
49.Inspect alternator idler pulley (if installed); remove front grease seal and add
grease. Refer to lubrication chart in Service Manual, Section II ............................
O
O
O
50.Inspect condition of alternator and starter ................................................................
O
O
O
51.Inspect security of alternator mounting ...................................................................
O
O
O
52.Cheek air conditioner compressor oil level (Read Note 13).....................................
O
O
O
53.Inspect condition of compressor belt and tension (Refer to Service Manual,
O
O
O
O
O
O
54.Inspect compressor clutch security and wiring .......................................................
O
O
O
55.Inspect security of compressor mounting.................................................................
O
O
O
56.Check fluid in brake reservoir (Fill as required) ......................................................
O
O
O
O
57.Lubricate all controls per lubrication chart in Service Manual, Section II............... O O O
58.Overhaul or replace propeller governor per manufacturer’s recommendations
O
O
O
59.Complete overhaul of engine or replace with factory rebuilt (Read Note(s) 5
and 28) ......................................................................................................................
O
O
O
60.Install the engine cowl..............................................................................................
O
O
O
O
E. CABIN GROUP
WARNING
Read Note 28 before completing this inspection group.
1. Inspect cabin entrance door and windows for damage, operation, and security ......
O
O
O
O
2. Inspect seats, seat belts, shoulder harness, security brackets and bolts (Read
Note 26) ....................................................................................................................
O
O
O
3. Inspect trim operation...............................................................................................
O
O
O
4. Inspect rudder pedals................................................................................................
O
O
O
5. Inspect parking brake and brake handle for operation and cylinder leaks................
O
O
O
6. Inspect control wheels, column, pulleys, chain, and cables (Read Note 23)............
O
O
O
7. Inspect flap control cable attachment bolt (See latest revision of Piper Service
O
O
O
8. Check landing, navigation, cabin, and instrument lights..........................................
O
O
O
O
9. Inspect instruments, lines, and attachments .............................................................
O
O
O
10.Inspect gyro-operated instruments and electric turn and bank (Overhaul or
replace as required)...................................................................................................
O
O
O
11.Replace instrument central air filter..........................................................................
O
O
O
12.Inspect or replace vacuum regulator filter................................................................
O
O
O
13.Check altimeter (Calibrate altimeter system in accordance with FAR 91.170,
O
O
O
50
500
1000
100
Inspection Time (Hrs)
CHEROKEE ARROW III SERVICE MANUAL
1D10
Interim Revision: 2/21/95
INSPECTION
Summary of Contents for ARROW III
