TABLE III-I. INSPECTION REPORT (cont)
Nature of Inspection
H. LANDING GEAR GROUP (cont.)
21.Retract gear, check operation and inspect doors for clearance and operation .........
O
O
O
22.Inspect operation of back-up gear extender system
(If not disabled) (Read Piper Service Bulletin 866.) (Read Note 27)........................... O O O
23.Inspect actuating cylinders for leaks and security ...................................................
O
O
O
24.Inspect all hydraulic lines, hoses, electrical leads, and attaching parts for
security, routing, chafing, deterioration, wear, and correct installation.
(Read latest revision of Piper Service Letter(s) 808 and 810)..................................
O
O
O
25.Inspect position indicator switch and electrical leads for security ..........................
O
O
O
26.Lubricate per lubrication chart in Service Manual, Section II..................................
O
O
O
O
27.Ensure landing gear is down and lockcd; remove airplane from jacks ....................
O
O
O
I. OPERATIONAL INSPECTION
1. Check fuel pump and fuel tank selector....................................................................
O
O
O
O
2. Check fuel quantity, pressure, and flow indications.................................................
O
O
O
O
3. Check oil pressure and temperature indications.......................................................
O
O
O
O
4. Check alternator performance...................................................................................
O
O
O
O
5. Check manifold pressure indications........................................................................
O
O
O
O
6. Check alternate air operation....................................................................................
O
O
O
O
7. Check parking brake operation.................................................................................
O
O
O
O
8. Check engine driven vacuum gauge indication........................................................
O
O
O
O
9. Check gyros for noise and roughness.......................................................................
O
O
O
O
10.Check cabin heater operation....................................................................................
O
O
O
O
11.Check magneto switches operation...........................................................................
O
O
O
O
12.Check each magneto RPM variation; drop etc .........................................................
O
O
O
O
13.Check throttle and mixture operation .......................................................................
O
O
O
O
14.Check propeller operation and smoothness..............................................................
O
O
O
O
15.Check propeller governor operation and reaction.....................................................
O
O
O
O
16.Check engine idle operation .....................................................................................
O
O
O
O
17.Check electronic equipment operation .....................................................................
O
O
O
O
18.Check automatic pitch trim, and manual/electric trim operation (Read Note 20)....
O
O
O
O
19.Check air conditioner compressor clutch operation .................................................
O
O
O
O
20.Check air conditioner condenser scoop operation....................................................
O
O
O
O
O
O
O
O
22.After shutdown, check auxiliary electric driven vacuum gauge indication..............
O
O
O
O
J. GENERAL.
1. Aircraft conforms to all FAA specifications.............................................................
O
O
O
O
2. All FAA Airworthiness Directives complied with....................................................
O
O
O
O
3. All manufacturers service bulletins and letters complied with.................................
O
O
O
O
4. Check for proper night manual.................................................................................
O
O
O
O
5. Aircraft papers in proper order .................................................................................
O
O
O
O
50
500
1000
100
Inspection Time (HRS)
CHEROKEE ARROW III SERVICE MANUAL
1D14
Issued: FEBRUARY 28, 1989
INSPECTION
Summary of Contents for ARROW III
