A. Scheduled Maintenance (continued)
4.
Periodic Inspection (continued)
—
NOTE —
Refer to Notes 1, 2, 3, and 4 before performing inspections.
PIPER AIRCRAFT
PA-32R-301/301T
MAINTENANCE MANUAL
5-20-00
Page 5-10
Reissued: July 1, 1993
1C15
NATURE OF INSPECTION
B. ENGINE GROUP (cont)
31.Inspect fuel system for leaks.........................................................................................
32.Inspect fuel pumps for operation (engine-driven and electric) .....................................
33.Overhaul or replace fuel pumps (engine-driven and electric) (see note 7) ...................
34.Inspect vacuum system pumps and lines. (Refer to note 23 for additional
instructions.)..................................................................................................................
35.Overhaul or replace vacuum pump(s). (Refer to notes 24 and 25 for additional
instructions.)..................................................................................................................
36.Inspect throttle, alternate air, mixture, and propeller governor controls for security,
travel, and operation condition......................................................................................
37.Inspect exhaust stacks, connections and gaskets. (Refer to chapter 78.) (Replace
gaskets as required.)......................................................................................................
38.Inspect muffler, heat exchange, and baffles. (Refer to chapter 78.)..............................
39.Inspect breather tube for obstructions and security.......................................................
40.Inspect crankcase for cracks, leaks, and security of seam bolts....................................
41.Inspect engine mounts for cracks and loose mounting .................................................
42.Inspect all engine baffles (also check engine baffle seals on PA-32R-301T)
43.Inspect rubber engine mount bushings for deterioration. (Replace as required.) .........
44.Inspect firewall seals.....................................................................................................
45.Inspect condition and tension of alternator drive belt. (Refer to chapters 21 and
24 if air conditioning is installed.) ................................................................................
46.Lubricate alternator idler pulley (if installed); remove front grease seal and add
grease. (Refer to lubrication chart, chapter 12.)............................................................
47.Inspect condition of alternator and starter.....................................................................
48.Inspect security of alternator or mounting ....................................................................
49.Check air conditioning compressor oil level. (Refer to note 9 for additional
instructions.)..................................................................................................................
50.Inspect condition of compressor belt and tension. (Refer to chapter 21 for additional
instructions.)..................................................................................................................
51.Inspect compressor clutch security and wiring. (Refer to note 10 for additional
instructions.)..................................................................................................................
52.Inspect compressor mounting for cracks, corrosion, and security ................................
50 100 500 1000
O
O
O
O
O
O
?
?
?
?
?
?
?
?
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
Inspection time (hrs)
Summary of Contents for PA-32R-301T SARATOGA S
