PERIODIC INSPECTIONS (cont.)
—Note—
Refer top Notes 1, 2, 3, and 4 performing inspections.
PIPER AIRCRAFT
PA-44-180/180T
AIRPLANE MAINTENANCE MANUAL
5-21-00
Page 5-09
Revised: June 20, 1995
1B8
50
100
500
1000
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
Inspection time (hrs)
Nature of Inspection
F. WING GROUP (cont)
4. Inspect aileron control stops to ensure stops have not loosened and lock-
nuts are tight..................................................................................................
5. Inspect aileron cables, pulleys and bellcranks for damage and operation
(Inspect bellcrank bearing for freedom of movement) (See Note 24)...........
6. Inspect flaps and attachments for damage and operation..............................
7. Inspect condition of bolts used with hinges (Replace as required)...............
8. Lubricate per lubrication chart (Refer to Chapter 12)...................................
9. Inspect wing attachment bolts and brackets..................................................
10. Inspect all control cables, air ducts, electrical leads and attaching parts for
security, routing, chafing, deterioration, wear and correct installation (See
Note 24).........................................................................................................
11. Inspect fuel tanks and lines for leaks and water (See Note 15).....................
12. Check that fuel tanks are marked for proper capacity...................................
13. Check that fuel tanks are marked for minimum octane rating ......................
14. Inspect fuel tank vents (See Note 16)............................................................
15. Inspect fuel tank nipple fittings for damage and proper torque (Refer to
16. Reinstall inspection plates and fairings.........................................................
G. LANDING GEAR GROUP
1 . Perform dye-penetrant inspection of main gear trunnion housing
2. Inspect oleo struts for proper extension (N = 2.70 ± .25 in. M = 2.60 ± .25
in.) (Check for proper fluid level, fill as required)........................................
3. Inspect nose gear steering control and travel.................................................
4. Inspect wheel alignment................................................................................
5. Put airplane on jacks (Refer to Chapter 7) ....................................................
6. Inspect tires for cuts, uneven or excessive wear and slippage.......................
7
Remove wheels, clean, check and repack bearings.......................................
8. Inspect wheels for cracks, corrosion and broken bolts..................................
9. Check tire pressure (N = 50 psi / M = 53 psi)...............................................
10. Inspect brake lining and disc.........................................................................
11 . Inspect wearing surfaces of brake disc for "heat checks" (Refer to
12. Inspect brake backing plates..........................................................................
Summary of Contents for SEMINOLE PA-44-180
