11. EFI SYSTEM OF SQR 472ENGINE
11-14
the C terminal. So it is in fact a angular potentiometer, potentiometer output and solar term door
position into a voltage signal proportional.
4) Technical parameters
The relationship between data for throttle valve opening and voltage as shown in the following table
Aperture(°) 0 10 20 30 40 50 60 70 80 85
（
Fully open
）
Voltage
（
V
）
0.33 0.78 1.25 1.71 2.17 2.63 3.08 3.52 3.99 4.5
Limit data
measure value
unit
Mechanical angle between two extreme
positions
119 angle
The throttle body electrical angle between
two extreme positions
8±2
angle
Slide arm current license
≤
18
μ
A
Storage temperature
-40+130
℃
Vibration acceleration license
≤
700 m/s
Characteristic data
value
measure
least typical
maximum
unit
Total resistance (pin A-B)
4.335
5.1
5.865
k
Ω
Slider protecting resistor (slider at
zero, pin B-C)
710
1380
Ω
Operating temperature
-40
130
℃
The power supply voltage
5
V
The right extreme position of the
voltage ratio
0.04
0.093
The left extreme position of the
voltage ratio
0.873
0.960
VP/Vcc with the throttle angle
increase rate
22 0.0009929
1/degree
Weight
25
28
g
5) The malfunction phenomenon and the judgment method
(1) The fault phenomenon: can not enter the idle state; or step on the accelerator, accelerate the
powerless;
(2) The cause of failure of internal short circuit or open circuit: sensor; or throttle body to the engine
control unit Connection or short circuit breakers.
(3) Note: repair is not removable solar term door position sensor
(4) A simple method to measure
The power supply voltage measurement sensor A and B ends of the 5V;
Resistors A and B ends of the value is about
Signal C solar term door idle position of voltage between 0.3~0.7V;
Signal C is fully open when the voltage to ground between 4.05~4.75V.
Summary of Contents for 1100 GKE OutLaw
