BODY / STEERING / SUSPENSION
5.5
TORQUE SPECIFICATIONS
Front A-Arm Attaching Bolt
30 ft. lbs. (41 Nm)
Front A-Arm Ball Joint Stud Nut
25 ft. lbs. (35 Nm)
Handlebar Adjuster Block
10-12 ft. lbs. (14-17 Nm)
Master Cylinder
45-55 in. lbs. (5.2-6.3 Nm)
Rear Axle Nut - (Tapered Roller Bearings)
(Left side)
120 ft. lbs. (165 Nm)
(Right side)
8-10 ft. lbs. (11-14 Nm)
Rear Shock Bolt (upper)
25 ft. lbs. (35 Nm)
Rear Shock Bolt (lower)
25 ft. lbs. (35 Nm)
Rear Wheel Hub Nut
80 ft. lbs. (110 Nm)
Rear Wheel Nut
50 ft. lbs. (69 Nm)
Strut Rod Retaining Nut (Top)
15 ft. lbs. (21 Nm)
Strut Casting Pinch Bolt
15 ft. lbs. (21 Nm)
Swing Arm Pivot Bolt
150 ft. lbs. (207 Nm)
Tie Rod End Jam Nut
12-14 ft. lbs. (17-19 Nm)
Tie Rod End Castle Nut
23-24 ft. lbs. (32-33 Nm)
Tie Rod End Attaching Bolt
25-30 ft. lbs. (35-41 Nm)
NOTE:
Refer to exploded views throughout this
chapter for identification and location of components.
SPECIAL TOOLS
PART NUMBER
TOOL
DESCRIPTION
2870871
Ball Joint
Replacement Tool
2870872
Shock Spanner
Wrench
2870623
Shock Absorber
Spring
Compression Tool
2871572
Strut Rod Wrench
2871573
LH Strut Spring
Compressor
2871574
RH Strut Spring
Compressor
COVER/PANEL REMOVAL
To remove, perform these steps:
Seat:
G
Pull release lever at the rear of the seat
G
Lift and pull seat rearward, disengaging
seat from tabs at the rear of the fuel tank
Side Panels
G
Remove: Seat
G
Disengage tabs at front and rear
Front Cover
G
Remove: Seat
G
Disengage tabs at front and rear
G
Lift panel out
Rear Rack
G
Remove: Seat
G
2 bolts at rear of rack
G
2 bolts at front of rack
Rear Cab Assembly
G
Remove: Seat
G
Rear rack
G
1 screw, nut and washer at rear of inner
left footrest
G
4 screws at bottom of left rear mudflap
G
1 screw, nut and washer at rear of inner
right footrest
G
4 screws at bottom of right rear mudflap
G
4 bolts and flat washers from top of cab
assembly, under seat
G
2 screws at rear bottom of cab assembly
near tail light
G
Disconnect taillight harness
PartShark.com
877-999-5686
Summary of Contents for 2009 Trail Blazer 330
