CARE AND MAINTENANCE 8-9
PA1633 X3-45 Commuter Operator’s Manual
CAUTION
During cold weather days, use windshield
washer fluid suitable for freezing temperature
only.
OTHER VERIFICATIONS
It is good practice to regularly inspect the vehicle
for signs of component wear and to perform
safety and maintenance routines.
AIR TANK PURGE
The vehicle is equipped with seven air tanks,
including the ping tank.
The wet tank is equipped with an automatic
drain valve and doesn’t need to be purged
manually.
The remaining tanks which are the primary,
secondary, the accessory, kneeling, and parking
brake overrule tanks are equipped with a drain
cock underneath the tank and must be purged
from moisture and contaminants every 12,000
miles. Drain tanks by turning drain cocks
counterclockwise. The accessory air tank drain
cock is accessible from the front service
compartment. The parking brakes overrule air
tank is located at the ceiling of the last baggage
compartment. Refer to the "Lubrication and
Service Check Point Chart" in this chapter for
tank locations.
FRONT SERVICE COMPARTMENT
12210
FIRE EXTINGUISHER
Inspect fire extinguisher monthly to insure
operation in emergency situations.
On extinguishers with a pressure gauge, the
needle should be in the green or NORMAL
range. Refill or replace extinguisher if pressure
is below normal;
Check that seal on handle is intact;
Check that hose nozzle is in good condition and
the nozzle is free of obstructions;
Keep fire extinguishers clean.
PRIMARY FUEL FILTER
A primary fuel filter is installed on the engine.
This filter may consist of a filter cartridge with a
drain valve at the bottom, or a filter cartridge, a
water separation bowl and may have a fuel
heater built in. It is used to prevent water from
entering the fuel system. The primary fuel filter
should be drained periodically or when the
telltale light on the dashboard illuminates if
equipped with this system. To drain water,
loosen the drain valve below the separator.
Close the drain valve when finished.
The optional Fuel Pro 382 diesel fuel filter
system consists of a permanently mounted fuel
processor, a replaceable filter element, a filter
element cover and collar and a fluid filter base
assembly. This system is installed between the
fuel tank and the fuel pump and replaces the
primary fuel filter. The filter serves as a water
separator as well as a fuel filter. To drain, turn ¼
turn the drain valve below filter, close when
water has been flushed out.
FUEL FILTERS WITH VOLVO D13 ENGINE
03085
Summary of Contents for X3-45 COMMUTER 2018
