Corporate
800.882.8854
49
--Remove one of the two dogear bolts closest to the front. The front left one works well.
--Rotate the strainer basket housing lid counter clockwise and slide the lid off the strainer
basket housing.
--If the lid does not rotate or slide, remove all the dogear bolts and gently pry the lid from
the strainer basket housing.
--Reach into the housing, grasp the strainer basket handle and twist the basket enough
to break it free in the event it is lodged. Lift the strainer basket in a twisting motion to avoid
breaking the handle and remove it from the housing.
--Remove and properly dispose of any large particulates that may have accumulated in the
strainer basket.
--Rinse the basket with fresh water. Once it is clean, replace the basket into the housing.
--Inspect basket strainer lid O-Ring by running a finger around the circumference of the
oring that is seated in the groove of the lid. It should not be cracked or cut and protruding
slightly above the sealing surface. Over time, the O-Ring may flatten and require
replacement. Check the basket sealing surface for debris. Clean as needed.
--Replace the lid and the dogear bolts.
--Tighten the dogear bolts in a cross pattern to ensure the strainer basket housing lid is
evenly seated on the housing. Leave the rear two slightly loose.
--Press Off, follow the touch screen instructions to reset the basket timer.
--When you press F4 the screen will say you have reset the basket timer.
--Go into Auto and prime the pump - tighten the two rear dogear bolts when water appears
as in the startup procedure on page 32.
NOTE: If this is a larger Reclaim with the
PVC strainer basket, reference page 32 for priming by loosening the bleed valve.
The basket is accessed by spinning the top off using the two protruding “ears” as
handles.
Basket Strainer with on ‘dog ear’
removed and
lid rotated for
removal
Basket Strainer lid
removed
Strainer basket being
removed
Basket Strainer with
one dogear bolt
removed and lid
rotated for removal
Basket Strainer lid
removed
Basket Strainer being
removed
Clean Basket Strainer Weekly
The Reclaim has a timer and will display a
message to clean the basket once per week.
Follow the system prompts.
--Turn the system to Hand mode. This will put the
system in bypass mode so that the carwash can
continue to run.
--Loosen the dogear bolts holding down the
strainer basket housing lid.
System Maintenance
See page 62
for detailed
instructions
Summary of Contents for PURWATER RECLAIM 3.0
Page 2: ...Corporate 800 882 8854 2...
Page 4: ...Corporate 800 882 8854 4...
Page 6: ...Corporate 800 882 8854 6...
