Page 5
March 2000
GB 40 I - FIREPLACE INSERT
SAFETY LABEL
(As found on chain in lower front grill.)
SAFETY LABEL
GB40 -I NG
GB40-I LP
GAS-FIRED VENTED ROOM HEATER
SERIAL NO.
MANUFACTURED BY:
401 N. Wynne
Colville, WA 99114
GB40-I (NG)
GB40-I (NG)
GB40-I (LP)
GB40-I (LP)
For use with Natural Gas
For use with Natural Gas For use with Propane For use with Propane
Altitude
0-2000'
2000-4500'
0-2000'
2000-4500'
Input High
46,000 BTUH
40,000 BTUH
40,000 BTUH
36,000 BTUH
Input Low
31,000 BTUH
29,000 BTUH
32,000 BTUH
25,000 BTUH
Output Blower off
33,600 BTUH
29,200 BTUH
30,000 BTUH
27,000 BTUH
Output Blower on
35,420 BTUH
31,000 BTUH
32,000 BTUH
28,440 BTUH
Manifold Pressure
3.5" WC
3.5" WC
10.0" WC
10.0" WC
Reduced Manifold Pressure 1.5" WC
1.5" WC
5.8" WC
5.8" WC
Min. Supply Pressure
4.5" WC
4.5" WC
11.0" WC
11.0" WC
Orifice Size (DMS)
Front burner
#53
#54
#66
#67
Middle Burner
#52
#53
#63
#64
Rear Burner
#38
#37
#53
#54
ATTENTION
This appliance must be installed in acordance with local codes, if any; if not,
follow current ANSI Z223.1/CAN 1-B149.
ELECTRICAL SUPPLY: 120 Volts, 1.2 Amps, 60 Hz.
Install and use only in accordance with manufacturer’s installation and operating instructions.
For direct discharge without duct connections.
Not for use with solid fuel.
Keep burner and control compartment clean.
Due to high surface temperatures, keep children, clothing and furniture away.
MANUFACTURED AS A:
GB40-I (NG)
GB40-I (LP)
MINIMUM CLEARANCES TO COMBUSTIBLES
FROM HEATER
SIDEWALL
A
10" (255mm)
MANTEL
C
12.5" (320mm)
MANTEL WIDTH
G
1" (25mm)
NOTE: FOR EVERY 1" (25mm) OF MANTEL WIDTH ADD 1" (25mm)
TO CLEARANCE “C”. EX: MANTEL WIDTH 6" (150mm) -
CLEARANCE “C” MUST BE 17.5" (445mm)
NON-COMBUSTIBLE HEARTH EXTENSION
HEARTH HEIGHT (H)
0" (0mm) 2" (51mm)
4" (100mm)
HEARTH DEPTH (I) 24" (610mm) 22" (560mm) 0" (0mm)
HEARTH WIDTH J 30" (760mm)
DO NOT REMOVE THIS LABEL
CAN 1-2.1-M86 / ANSI 21.11.1a-1993
Report #061-S-07-4
