3.5 Equalizing Charge / 3.6 Equalization by customer
3.5
EQUALIZING CHARGE
The Batteries in car require an
‘Equalizing’ charge at periodic intervals
(approx. 500 miles of running). This is
automatically carried out by the G-wiz’s
internal system. The equalization charge
takes about 10 hours after the full
charge. The car indicates equalization by
alternatively flashing the charge(green)
light and the ‘Low Battery’ light. It is
advisable not to disturb the equalization
charge until the green lights turns
permanently ON.
3.6
EQUALIZATION BY
CUSTOMER
a)After charge, if charge(Green) and low
battery(red symbol) is flashing
alternately, it is indication of
Equalization charge “Keep it
undisturbed for 10 Hrs, by this time
equalization will be completed and
charge light will be Solid green”.
b)In case it has to be disturbed before
completion of 10 hrs, ensure
that in the next five cycle of
charge, the balance of 10 hrs for
equalization is completed.
(There will be no indication, when
remaining equalization will happen).
Charging your Gwiz
c) There will be no indication if the
equalization has not been
completed. Once every month,
manually initiate equalization by
following procedure.
(i) Sit in the car, close both doors and
release parking brake.
(ii) Turn “ON and OFF” the key switch
three times. Ensure that all the
lights in the IP come on and go off
each time it is switched ON.
(ii) Beep sound will be heard as an
acknowledgment of “Equalization”
command
(iii) Plug in charge plug and after full
charge equalization will start
automatically and will continue for
10 hrs after the full charge.
If the car has been stationary for few days,
for manual equalization Key ON-OFF may
need to be repeated a fourth time.
NOTE
Equalizing uses a lot of battery water so you
may find that you need to water afterwards.
NOTE
It is recommended that you carry out manual
battery equalization once in every month if
you do not get a chance to complete
automatic equalization
NOTE
40
3.4 Under Charging / Over Charging
3.4 UNDER-CHARGING /
OVER-CHARGING
YOUR Gwiz
This can never happen, as your car is an
intelligent car. The car’s unique Energy
Management System [EMS] controls
the flow of electricity from the power
supply to the Power Pack. It will draw
only the required power to charge the
Power Pack completely.
Furthermore, if there is voltage
fluctuation or an interruption in power
supply, the computer controlled on-
board charger remembers the point at
which charging was interrupted and
resumes charging from where the
charging stopped. It also has an auto
shut-off mechanism by which the
charging automatically stops once the
Power Pack is completely charged.
After completing the charging
process, first switch off power
supply at the external power source.
Then remove / disconnect the
charging cable from the source and
the on-board charge port in this
order. Roll up and store charging
cable in its compartment behind the
rear seat of your car.
NOTE
Charging your Gwiz
39
Downloaded from
www.Manualslib.com
manuals search engine
Summary of Contents for G-Wiz
