5
Eye Protection
The use of safety goggles is highly recommended (normal glasses are not sufficient for eye protection) when using an air
compressor. Prescription glasses do not have safety lenses.
Footwear
Where there is the risk of heavy objects or if there is a risk of slipping on wet or slippery floors, suitable non
–slip safety
footwear should be worn. Protect your feet from dropping accidents.
Ear Protection
The use of ear protection is highly recommended when using air compressors. The continual noise may damage your
ears.
Respiratory Protection
When operating any machinery that creates dust or when spray painting, an approved dust / filter mask must be worn.
When machining concrete, man made fibres, especially MDF (Medium Density Fibre board), the resin used in these
materials can be hazardous to your health. Use an approved face mask with replaceable filter.
Do Not Over Reach
Do not over reach. Keep a proper footing and maintain your balance at all times. Avoid using abnormal stances and
awkward body positions.
Stay Alert
Watch what you are doing, use common sense, and never operate an air compressor when you are tired, drinking
alcohol, taking drugs or if taking medication that causes drowsiness.
Electrical Data
IMPORTANT
This air compressor is fitted with a sealed electrical connection plug that is compatible with the
mains power supply for Australia / New Zealand and meets the requirements of international
standards. This air compressor must be connected to a supply voltage that is equal to that stated
on the rating label. If the mains power connection plug or power cord becomes damaged it must be
replaced with a complete assembly that is identical to the original, and this must be replaced by an
authorised service centre. Always follow the Australian / New Zealand requirements for connection
to the mains supply. If in doubt always consult a qualified electrician.
Specific Safety Instructions
Warning! Do not use the air compressor in areas where there is a risk of explosion or fire from combustible materials.
The sparks generated from certain tools attached to air compressor can ignite combustible materials as well as flammable
liquids, paint, varnish, petrol, flammable gases and dust of an explosive nature. As a precaution it is recommended that
you consult an expert on a suitable fire extinguisher and its use.
Initially remove the dust cover and replace with the oil breather BEFORE using the
first time, see page 10.
Do not attempt to modify the air compressor, guards or the supplied accessories
in any way.
Domestic air compressors are designed for intermittent operation. Ideally a 50%
duty cycle. (Meaning. 30 seconds ON motor pumping and 30 seconds OFF, motor
not pumping). When the motor is pumping the attached air tool cannot be used.
Only use the attached air tool while the compressor is not pumping.
Stop using the attached tool as soon as the air compressor starts pumping.
Always check the oil level before use. Oil level should be above the red mark on
the sight glass.
Fully assemble compressor before use.
