Sames
13, chemin de Malacher
38240 Meylan - France
Tel. 33 (0)4 76 41 60 60
Page 1/3
PMP582221110-Xcite+ NewDesign, Xcite+ .
Updated on 21.12.2022 L. Da Sylva .
Pistolet Xcite+/
Light
PMP582221110
PLAN DE MAINTENANCE PREVENTIVE
/ PREVENTIVE MAINTENANCE PLAN
100eme H
mn
M
F
E
A
1
2
1
Corps de pistolet
Body
Vérification mise à la terre par un
tuyau statique
Checking ground connection
0,17
0,10
1/utilisation
X
1
Avant chaque début de production
Before each production start
2
Corps de pistolet
Body
Contrôle usure / fuite
Wear / Leakage check
0,17
0,10
1/utilisation
X
1
Avant chaque début de production
Before each production start
3
Tuyaux
Hoses
Vérification état et bon
fonctionnement
Checking the state and proper
functioning
0,17
0,10
1/utilisation
X
1
Avant chaque début de production
Before each production start
4
Vannes
Valves
Vérification état et bon
fonctionnement
Checking the state and proper
functioning
0,17
0,10
1/utilisation
X
1
Avant chaque début de production
Before each production start
5
Partie produit
Fluid part
Nettoyer au solvant ou à l'eau
Rince with solvant or clean water
25,00
15,00
1/utilisation
X
1
A chaque arrêt de production
Every break time
6
Corps de pistolet
Body
Nettoyer le pistolet
Clean the gun
25,00
15,00
1/utilisation
X
1
A chaque arrêt de production
Every break time
7
Buse
Tip
Nettoyer l’extérieur de la buse
avec un pinceau et du solvant
(pas de nettoyage à ultrason)
Clean the outside of the tip with
a brush and solvent (no
ultrasonic cleaning)
1,67
1,00
1/utilisation
X
1
Après chaque utilisation
After each use
8
Buse
Tip
Démonter la buse et l’immerger
dans un petit récipient contenant
du solvant
Disassemble the tip and immerse
it in a small container containing
solvent.
3,33
2,00
1/utilisation
X
1
En fin de journée de travail
After a working day
9
Joint de tête
Seal, aircap
Remplacement
Replacement
3,33
2,00
1/an
X
1
A remplacer si endommagé
Replace if broken
10
Joint de bague
Seal, ring
Remplacement
Replacement
3,33
2,00
1/an
X
1
A remplacer si endommagé
Replace if broken
11
Porte siège
Seat-holder
Contrôle aspect
Wear / Leakage check
1,67
1,00
1/mois
X
1
A remplacer si endommagé
Replace if broken
12
Porte siège
Seat-holder
Remplacement
Replacement
3,33
2,00
1/an
X
1
A remplacer si endommagé
Replace if broken
13
Joint torique
O-ring
Remplacement
Replacement
3,33
2,00
1/an
X
1
A remplacer si endommagé
Replace if broken
Outil
Tool
(1)
Temps moyen d'intervention à titre indicatif, et à ajuster par les équipes d'intervention du site
/ This average intervention time is given for information and should be adjusted by the operating teams on site.
(2)
Les périodicités mentionnées sont des moyennes basées sur l’expérience de
Sames
. A charge des utilisateurs de les adapter aux conditions de leur installation notamment en fonction de la nature des produits utilisés, des vitesses de travail, etc.
Sames
se réserve le droit de modifier les informations mentionnées dans ce document, sans préavis
/
The given periodicities are averages based on
Sames
experience. It is the responsibility of the operators to adapt them to the conditions of their installation, in particular with respect to the nature of the products being used, the work speeds, etc. Sames reserves the right to change the information in this document without notice.
(3)
M : Mécanicien - F : Spécialiste fluide - E : Electricien - A : Automaticien
/ M : Mechanic - F : Fluid specialist - E : Electrician - A : Automation specialist
(4)
1 = Niveau de Base, 2 = Niveau Avancé
/ 1 = Basic level, 2 = Advanced level
Avant toute intervention, se référer au chapitre sécurité du manuel de l’équipement /
Before any intervention, see chapter safety equipment manual
Avant toute intervention sur la pompe, couper l'alimentation en air comprimé et décompresser les circuit
s / Before working on the pump, shut off the compressed air circuits and decompress
Ensemble
-
Assembly
Commentaires
Notes
N
um
éro
d
'o
rd
re
S
er
ia
l
Sous ensemble
Sub assembly
Désignation de l'élément
Designation of the assembly
Pour 1 ensemble
-
For 1 assembly
Acteurs Métiers
Operators - skill
(3)
Niveau
Level
(4)
Action à effectuer
Action to carry out
Temps prévu
Estimated Time
(1)
Périodicité
Periodicity
(
H
/ hour)
(2)
Manuel
d'utilisation
Instruction
manual
Général
General
Equipement
Equipment
Partie produit
Fluid part
Tête complète
Aircap equipped
Porte-siège équipé
Seat-holder assembly