SY265C LC/SY265C LR Excavator OMM
SANY
Operation and Maintenance Manual — 0420
5-63
TABL
E OF
CONT
E
N
TS
INTRODUCTION
SAFE
T
Y
MACHIN
E
CONTROLS
MACHINE
OP
ERA
T
IO
N
MA
INTENANCE
SPEC
IFI
CA
TIO
N
S
OP
T
IO
N
A
L
EQUI
PMENT
7. Check the top surfaces and all battery connections (3)
for signs of corrosion or dirt buildup.
8. Use a clean rag to wipe any dirt from the batteries.
NOTE:
If corrosion is found, flush the area with a
battery cleaning solution.
9. Remove any trash, tools, parts, or debris from the
battery compartment.
10. Install the cover.
11. Close and secure left access doors.
Replace the Batteries
1. Prepare the machine for checks and inspections. See
“Maintenance Safety” on page 2-8.
2. The batteries are under the cover (1) behind the left
rear access door. See “Left Access Doors” on page 4-
10.
WARNING!
Before proceeding with any battery maintenance procedure, observe the following:
•
The top of the battery must be kept clean to prevent plugging of the battery vents.
Regularly wash the top of the battery to prevent the battery vents from plugging.
•
Battery gases are explosive. Never smoke around batteries or expose them to sparks or
open flames. Work in a well-ventilated area.
•
Wear personal protective equipment (PPE) when working with batteries.
•
Battery acid can cause burns or injury. If battery acid makes contact with skin or eyes,
flush the area immediately with fresh water and seek medical attention.
Failure to follow these warnings could result in death or serious injury.
Fig. 5-74
3
Fig. 5-75
1
2
Summary of Contents for SY265C LC
Page 2: ...Page Intentionally Blank ...
Page 287: ...Page Intentionally Blank ...
