CAPACITOR AND RESISTOR CODE CHART
CAPACITOR (Example)
500 C K 1500 B
D ........................... ±0.5pF
T ............................ +50%
–
10%
J ............................ ±5%
K ........................... ±10%
M ........................... ±20%
N ........................... ±30%
Characteristics
P ...........................
+100% –
0%
Value code
Z ........................... +80%
–
20%
Tolerance code
C ........................... ±0.25pF
Material code
C ........................... Ceramic
Voltage rating
E ........................... Electrolytic
F ........................... Polyester
N ........................... Polypropylene
T ............................ Tantalum
K ........................... Ceramic
H ........................... MT-Composite
P ........................... NP. Electrolytic
M ........................... MT-Polypropylene
RESISTOR (Example)
6 Y K 4.7
D ........................... ±0.5%
F ........................... ±1%
G ........................... ±2%
J ............................ ±5%
Value code
K ........................... ±10%
Tolerance code
M ........................... ±20%
Material code
F ............................ Fusible
Wattage rating
N ........................... Metalized Carbon
S ........................... Oxide Metalized
Y ........................... Wire Wound
C ........................... Solid
D ........................... Carbon Film
W .......................... Wire Wound
— 29 —
— 30 —
— 32 —
— 31 —
FOR CONTINUED PROTECTION AGAINST
A RISK OF FIRE, REPLACE ONLY WITH
THE SAME TYPE 4A, 125V FUSE.
ATTENTION: POUR MAINTENIR LA PROTECTION
CONTRE LES RISQUES D' INCENDIE UTILISER UN
FUSIBLE DE RECHANGE DE MEME TYPE 4A, 125V.
CAUTION
4A 125V
BLOCK DIAGRAM
17
42
41
40
39
25
29
3
27
OSD (R)
OSD (G)
OSD (B)
OSD (BLK)
RESET
AFT S-CURVE
POWER FAIL
POWER
ON/OFF
STANDBY MODE
5V
CONTROL
Q693,
Q695
Q635
OVERLOAD
PROTECT.
D612
PHOTO
COUPLER
IC601
POWER
REG.
Q681
12V SW
DRIVE
IC681
5V REG.
D601-D604
FULL WAVE
RECTIFIER
Q605
ERR.
AMP.
Q604
OSC
Q601
SW.
T601
CONVERTER
TRANS.
LF601
LINE
FILTER
PS601
POSISTOR
RL601
RELAY
L901
DEGAUSING
COIL
AC120V
60Hz
F601
AC
FUSE
C601
D627
+16V
+130V
D621
D694
D624
D625
4A 125V
+12V
Q627
12V SW.
Y CV IN
12
13
14
15
8
IC101
SIGNAL PROCESS
SDA 9
SCL 10
78/79
11
Y 52
C 54
49
44
Q135
BUFFER
PIP VCC
3.3V
BEAM
VOLTAGE
DETECT.
ABL-IN
MUTE
S1-SW
S2-SW
PIP TV/AV
PIP AV 1/2
MAIN AV 1/2
Q208
CAP
VIDEO
OUT
RF AGC 77
ACL
X141
SAW
FILTER
INT. VIDEO
C1/C2
PIP CVBS IN
Q8073
Q8083
Q8076
CVBS
IN
23
24 25
45
47
8
51 49
32
Q8005
Q8006
33
22
13
IC8001
PIP CONTROLER
Q8090
SDA
SCL
C
Y
H-SYNC
V
-SYNC
Q8093
Q8097
C
Y
PIP
SYNC
IN
Q831
RESET
A101
UHF/VHF TUNER
WITH PLL
& BAND SW
IF
AGC
IC802
EEPROM
6
7
A1901
RC PRE-AMP
SW1901-1906
CONTROL KEYS
RF AGC
BUS SCL
BUS SDA
IIC SCL
IIC SDA
RC IN
KEY IN
X IN
X OUT
28
34
32
33
31
10
9
19
20
30
38
2
1
H-S
V-S
IC801
CPU
WITH
CAPTION
DECODER
X 801
ANT
C809
C808
12
35
7
6
5
IC501
VERT.
OUTPUT
Q401
HORIZ.
DRIVE
T401
H-DRIVE
TRANS.
Q402
HORIZ.
OUTPUT
HOLD DOWN
DETECT.
30
40
17
18
19
HOLD DOWN
T402
HORIZ.
OUTPUT
TRANS.
H.V.
AFC
DEFLECTION
YOKE
ABL
FOCUS
SCREEN
HEATER
V +B
5
6/7
4
9
3
4
1
V
H
2
H-PULSE
ABL
Y/V SELECT
Q721
Q711
Q701
-R OUT
-G OUT
-B OUT
R
G
B
Q901
PIX TUBE
D481
200V
(7V)
D429
D428
(16V)
R428
g7jam
ANODE LEAK
DETECT.
L164
X161
75
SIF
56
37
36
33
26
4.5MHz
SOUND
TRAP
IC001
AUDIO
AMP.
10
8
5
3
1
(L)
(R)
K1021
FIXED
AUDIO OUT (L)
K1011
FIXED
AUDIO OUT (R)
SP901
SPEAKER
(R)
SP902
SPEAKER
(L)
MUTE
Q001
4
3
39
38
A
V
2 R
A
V
1 L
A
V
1 R
A
V
2 L
33
37
36
34
13
IC3401
MTS DECODER
K1001 A/V 1 IN
VIDEO IN
AUDIO IN (L)
AUDIO IN (R)
D482
VIDEO
H-S
V-S
5
L
R
Y
Y1 IN
C1 IN
S1 SW
C
K1051
S1 IN AV1
Y
K1002 A/V 2 IN
VIDEO IN
AUDIO IN (L)
AUDIO IN (R)
S1 SW
PIP AV 1/2
PIP
TV/AV
CVBS PIP
11 14 10 4
9 15
IC1002
SELECT CVBS
FOR PIP
13 12 5
3
2 1
INT. V
FOR PIP
EXT
.
V IN
FOR PIP
13 V2 IN
5 C1 IN
2 Y1 IN
1 V1 IN
H
H
H
L
L
L
H
H
H
L
L
L
Q1097
Q1096
S2-SW 11
V2 14
MAIN AV 1/2 9
C1 4
S1-SW 10
V1/Y1 15
V2
V1/Y1
IC1001
SELECT V/Y + C1/C2
5
6
SDL
SCL
Q202
BUFFER
IN SELECT
OUT SELECT
13
11
7 SC
3
2
12
Y/V SELECT
INT
. VIDEO
S CLOCK 3.58
16 14
15
9
1
COMB
FILTER
C Y
C1/C2
H PULSE
RESET
OSD
SW.
RGB
OUT
CONT
BRITE
COLOR
DEMOD
SHARP
BPA
BLACK
STRETCH
DELAY
LINE
SYNC
SEP.
HORIZ.
DRIVER
VIDEO
DET.
FM
DET.
BUS
INTERFACE
H
V
VIDEO
SW.
+12V
32
5V
B9
Q486
9V REG.
Q490
5V REG.
Q8000
3.3V REG.
5V
ALWAYS
B9
12V
B4
9V
5V
B6
D801
D483
+26V
D508
MODEL DS27820
Chassis No. 27820-00
SCHEMATIC DIAGRAMS
SERVICE NOTES:
1. When replacing parts on circuit boards, clamp the lead wires to terminals before soldering.
2. When replacing high wattage resistors on circuit board, keep the resistor body 10 mm (3/8) from circuit board.
3. Keep wires away from high voltage and high temperature components.
PRODUCT SAFETY NOTICE
THE COMPONENTS DESIGNATED BY A STAR (
★
) ON THIS SCHEMATIC DIAGRAM DESIGNATE COMPONENTS
WHOSE VALUES ARE OF SPECIAL SIGNIFICANCE TO PRODUCT SAFETY. SHOULD ANY COMPONENT
DESIGNATED BY A STAR NEED TO BE REPLACED, USE ONLY THE PART DESIGNATED IN THE PARTS LIST. DO NOT
DEVIATE FROM THE RESISTANCE, WATTAGE AND VOLTAGE RATINGS SHOWN.
X-RADIATION WARNING NOTE
THIS TV CONTAINS CRITICAL PARTS TO PROTECT AGAINST X-RADIATION. NOMINAL 2ND ANODE VOLTAGE IS
29.0KV AT ZERO BEAM CURRENT AT 120 VOLTS AC LINE, AND MUST NOT EXCEED 30.0KV UNDER ANY
OPERATING CONDITION. SEE HIGH VOLTAGE CHECK ON PAGE 8.
1
1
1
1
TOP VIEW
SIDE VIEW
COUNT TERMINALS IN
ARROW DIRECTION
MARK
E
C
B
A
K
A
K
A
K
A
K
A
K
A
K
INFRARED EMITTING
A....ANODE
K....CATHODE
INTEGRATED CIRCUITS
TRANSISTORS
1
DIODES
PHOTO COUPLERS
B ... BASE
C ... COLLECTOR
E ... EMITTER
E C
B
E C
B
E
C
B
E
C
B
E C
B
E
C
B
E C
B
E
C
B
3
2
1
3 2
1
GND
(2)
IN
(1)
OUT
(3)
1
1
TOP VIEW
1
CHIP TRANSISTORS
B
C
E
TOP VIEW
B ... BASE
C ... COLLECTOR
E ... EMITTER
CHIP RESISTORS
TOP VIEW
123
12 x 10 = 12K ohm
3
NOTES ON SCHEMATIC DIAGRAMS
1. All resistance values in ohms K=1,000 M=1,000,000.
2. Unless otherwise noted on schematic, all capacitor values less than 1 are expressed in µF (Micro Farad),
and the values more than 1 are in pF.
3. Unless otherwise noted on schematic, voltage reading taken with VOM from point indicated to chassis
ground. Voltage reading taken using color-bar signal VHF channel 5, all controls at normal. Line voltage at 120
volts. Some voltages may vary with signal strength.
4. Waveforms were taken with color-bar signal and controls adjusted for normal picture. Waveforms marked
with an
✽
may vary with signal strength.
5. The Symbol indicates a fusible resistor, which protects the circuit from possible short circuits.
WAVEFORMS
NOTE: Waveforms were taken with color-bar signal and the controls adjusted for normal picture.
IC101-
17
(R-Output)
2.0V HORIZ
IC101-
18
(G-Output)
2.0V HORIZ
IC101-
19
(B-Output)
2.0V HORIZ
IC101-
52
(Selected Video)
1.0V HORIZ
IC501- 2
(Vertical Output)
58 VERT
IC501- 5
(Inverting Input)
0.6V VERT
Q202-E (TP16)
(Internal Video)
1.0V HORIZ
Q401- B
(Horizontal Drive)
0.7V HORZ
Q402- B
(Horizontal Output)
13V HORZ
T402- 9
(Heater)
28V HORIZ
Q601- B
(Power Switching)
6.0V 50KHz
VOLTAGE CHARTS
NOTE: Voltages were measured using color-bar signal and the controls adjusted for normal picture.
Device/Pin #
Volts/Mode
IC101-42
GND
IC101-43
GND
IC101-44
2.2
IC101-45
3.7
IC101-46
2.0
IC101-47
3.0
IC101-48
0
IC101-49
2.5
IC101-50
GND
IC101-51
GND
IC101-52
2.8
IC101-53
5.2
IC101-54
2.7
IC101-55
2.7
IC101-56
2.3
IC101-57
GND
IC101-58
3.6
IC101-59
4.4
IC101-60
4.4
IC101-61
GND
IC101-62
GND
IC101-63
GND
IC101-64
GND
IC101-65
2.5
IC101-66
2.3
IC101-67
1.9
IC101-68
2.5
IC101-69
3.2
IC101-70
GND
IC101-71
GND
IC101-72
GND
IC101-73
2.3
IC101-74
0
IC101-75
2.3
IC101-76
2.7
IC101-77
2.3
IC101-78
2.9
IC101-79
2.9
IC101-80
GND
IC301-1
0.9
IC301-2
4.8
IC301-3
2.0
IC301-4
0
IC301-5
5.1
IC301-6
5.1
IC301-7
0.3
IC301-8
–0.3
IC301-9
0.6
IC301-10
0
IC301-11
0
IC301-12
1.5
IC301-13
GND
IC301-14
1.9
IC301-15
0
IC301-16
1.5
IC501-1
GND
IC501-2
13.7
IC501-3
27.1
IC501-4
2.9
IC501-5
2.9
IC501-6
26.2
IC501-7
3.0
IC501-8
2.9
IC501-9
2.9
IC501-10
13.3
POWER ON:
POWER OFF:
IC601-1
129.2
92.5
POWER ON:
POWER OFF:
IC601-2
31.1
9.8
IC601-3
GND
IC681-1
POWER ON:
POWER OFF:
(IN)
11.6
7.3
IC681-2
GND
IC681-3
POWER ON:
POWER OFF:
(OUT)
5.0
5.0
IC801-1
4.0
IC801-2
3.9
IC801-3
4.9
IC801-4
9.1
IC801-5
0
IC801-6
0
IC801-7
0
IC801-8
0.3
IC801-9
0
IC801-10
4.9
IC801-11
0
IC801-12
4.8
IC801-13
4.9
IC801-14
4.9
IC801-15
1.9
IC801-16
0.2
IC801-17
2.1
IC801-18
GND
IC801-19
2.2
IC801-20
2.0
IC801-21
GND
IC801-22
4.9
IC801-23
0.2
IC801-24
0.2
IC801-25
4.8
IC801-26
0.3
POWER ON:
POWER OFF:
IC801-27
4.9
0
IC801-28
2.3
IC801-29
2.6
IC801-30
0
IC801-31
4.9
IC801-32
3.6
IC801-33
4.9
IC801-34
3.7
IC801-35
4.8
IC801-36
4.9
IC801-37
4.9
IC801-38
0
IC801-39
0
IC801-40
0
IC801-41
0
IC801-42
0
Device/Pin #
Volts/Mode
POWER ON:
POWER OFF:
D612-1
31.9
10.9
POWER ON:
POWER OFF:
D612-2
31.0
9.8
POWER ON:
POWER OFF:
D612-3
–.3
0.6
POWER ON:
POWER OFF:
D612-4
13.3
1.4
IC001-1
7.4
IC001-2
GND
IC001-3
7.7
IC001-4
15.5
IC001-5
7.9
IC001-6
10.8
IC001-7
2.2
IC001-8
1.4
IC001-9
GND
IC001-10
1.4
IC101-1
GND
IC101-2
GND
IC101-3
GND
IC101-4
GND
IC101-5
GND
IC101-6
5.1
IC101-7
2.0
IC101-8
2.6
IC101-9
3.6
IC101-10
3.7
IC101-11
4.0
IC101-12
1.5
IC101-13
1.5
IC101-14
1.5
IC101-15
0
IC101-16
8.3
IC101-17
2.5
IC101-18
2.5
IC101-19
2.5
IC101-20
2.25
IC101-21
GND
IC101-22
GND
IC101-23
GND
IC101-24
GND
IC101-25
2.0
IC101-26
2.4
IC101-27
2.6
IC101-28
5,3
IC101-29
2.8
IC101-30
0.6
IC101-31
GND
IC101-32
4.9
IC101-33
1.0
IC101-34
1.8
IC101-35
4.8
IC101-36
3.9
IC101-37
4.0
IC101-38
4.7
IC101-39
GND
IC101-40
0
IC101-41
GND
Device/Pin #
Volts/Mode
IC8001-29
0
IC8001-30
GND
IC8001-31
N.C.
IC8001-32
0.4
IC8001-33
0.3
IC8001-34
3.1
IC8001-35
3.1
IC8001-36
GND
IC8001-37
3.0
IC8001-38
0.9
IC8001-39
2.9
IC8001-40
1.2
IC8001-41
1.2
IC8001-42
GND
IC8001-43
0.9
IC8001-44
3.2
IC8001-45
0.9
IC8001-46
3.2
IC8001-47
1.0
IC8001-48
GND
IC8001-49
1.0
IC8001-50
GND
IC8001-51
0.9
IC8001-52
GND
POWER ON:
POWER OFF:
Q001-B
0
0.7
POWER ON:
POWER OFF:
Q001-C
7.7
0
Q001-E
GND
Q135-B
2.3
Q135-C
5.2
Q135-E
1.7
Q202-B
2.7
Q202-C
GND
Q202-E
3.4
Q208-B
2.8
Q208-C
GND
Q208-E
3.5
Q401-B
0.3
Q401-C
43.6
Q401-E
GND
Q402-B
-0.1
Q402-C
125.26
Q402-E
GND
Q446-B
4.0
Q446-C
GND
Q446-E
4.7
Q486-B
9.9
Q486-C
11.6
Q486-E
9.1
Q490-B
5.9
Q490-C
6.9
Q490-E
5.2
POWER ON:
POWER OFF:
Q601-B
–0.3
0
POWER ON:
POWER OFF:
Q601-C
155.0
169.6
Q601-E
GND
Device/Pin #
Volts/Mode
IC3401-19
9.1
IC3401-20
0
IC3401-21
4.1
IC3401-22
4.1
IC3401-23
3.7
IC3401-24
3.9
IC3401-25
4.1
IC3401-26
4.1
IC3401-27
4.1
IC3401-28
1.9
IC3401-29
4.1
IC3401-30
4.1
IC3401-31
2.0
IC3401-32
4.1
IC3401-33
4.1
IC3401-34
4.1
IC3401-35
0
IC3401-36
4.1
IC3401-37
4.1
IC3401-38
4.1
IC3401-39
4.1
IC3401-40
4.1
IC3401-41
4.1
IC3401-42
GND
IC3401-43
4.1
IC3401-44
4.1
IC3401-45
4.2
IC3401-46
GND
IC3401-47
4.1
IC3401-48
4.1
IC8001-1
GRD
IC8001-2
2.1
IC8001-3
1.6
IC8001-4
1.8
IC8001-5
1.6
IC8001-6
3.2
IC8001-7
3.2
IC8001-8
0.9
IC8001-9
1.4
IC8001-10
0.5
IC8001-11
GND
IC8001-12
3.2
IC8001-13
0.8
IC8001-14
1.4
IC8001-15
0.5
IC8001-16
GRD
IC8001-17
3.1
IC8001-18
GRD
IC8001-19
3.1
IC8001-20
N.C.
IC8001-21
0
IC8001-22
0.2
IC8001-23
0.1
IC8001-24
0.3
IC8001-25
2.2
IC8001-26
GND
IC8001-27
3.1
IC8001-28
N.C.
Device/Pin #
Volts/Mode
IC802-1
GND
IC802-2
GND
IC802-3
GND
IC802-4
GND
IC802-5
4.9
IC802-6
4.9
IC802-7
GND
IC802-8
4.9
IC1001-1
0
IC1001-2
0
IC1001-3
6.5
IC1001-4
6.5
IC1001-5
6.5
IC1001-6
GND
IC1001-7
GND
IC1001-8
GND
IC1001-9
0
IC1001-10
0
IC1001-11
9.3
IC1001-12
0.7
IC1001-13
2.5
IC1001-14
2.5
IC1001-15
0
IC1001-16
9.3
IC1002-1
6.3
IC1002-2
6.2
IC1002-3
2.4
IC1002-4
2.7
IC1002-5
2.7
IC1002-6
GND
IC1002-7
GND
IC1002-8
GND
IC1002-9
0
IC1002-10
0
IC1002-11
0
IC1002-12
6.0
IC1002-13
6.2
IC1002-14
6.0
IC1002-15
6.2
IC1002-16
9.1
IC3401-1
4.1
IC3401-2
4.1
IC3401-3
4.1
IC3401-4
4.1
IC3401-5
3.6
IC3401-6
3.7
IC3401-7
GND
IC3401-8
4.1
IC3401-9
4.1
IC3401-10
4.1
IC3401-11
4.1
IC3401-12
4.9
IC3401-13
4.1
IC3401-14
1.3
IC3401-15
1.3
IC3401-16
0
IC3401-17
GND
IC3401-18
3.2
Device/Pin #
Volts/Mode
Device/Pin #
Volts/Mode
Q8000-B
3.9
Q8000-C
4.2
Q8000-E
3.2
Q8005-B
0.6
Q8005-C
0.3
Q8005-E
GND
Q8006-B
0.6
Q8006-C
0.2
Q8006-E
GND
Q8073-B
4.3
Q8073-C
9.0
Q8073-E
0
Q8076-B
3.7
Q8076-C
GND
Q8076-E
4.4
Q8083-B
2.9
Q8083-C
0.2
Q8083-E
3.1
Q8090-B
0
Q8090-C
3.4
Q8090-E
GND
Q8093-B
1.8
Q8093-C
2.1
Q8093-E
3.4
Q8097-B
1.9
Q8097-C
2.2
Q8097-E
3.3
POWER ON:
POWER OFF:
Q604-B
–0.4
0.6
POWER ON:
POWER OFF:
Q604-C
–0.3
0
Q604-E
GND
POWER ON:
POWER OFF:
Q605-B
13.1
1.4
POWER ON:
POWER OFF:
Q605-C
–0.4
0.6
POWER ON:
POWER OFF:
Q605-E
13.0
2.0
POWER ON:
POWER OFF:
Q627-B
11.1
7.3
POWER ON:
POWER OFF:
Q627-C
11.6
1.0
POWER ON:
POWER OFF:
Q627-E
11.9
7.3
POWER ON:
POWER OFF:
Q635-B
4.2
1.4
POWER ON:
POWER OFF:
Q635-C
31.1
9.8
POWER ON:
POWER OFF:
Q635-E
4.2
1.4
POWER ON:
POWER OFF:
Q681-B
0.7
0
POWER ON:
POWER OFF:
Q681-C
0
7.3
Q681-E
GND
POWER ON:
POWER OFF:
Q693-B
0.5
6.2
POWER ON:
POWER OFF:
Q693-C
30.9
8.9
POWER ON:
POWER OFF:
Q693-E
0.4
5.7
POWER ON:
POWER OFF:
Q695-B
30.9
9.6
Q695-C
GND
POWER ON:
POWER OFF:
Q695-E
31.0
9.8
Q701-B
2.6
Q701-C
141.9
Q701-E
2.5
Q711-B
2.6
Q711-C
143.1
Q711-E
2.5
Q721-B
2.6
Q721-C
146.1
Q721-E
2.5
Q831-B
4.9
Q831-C
4.9
Q831-E
4.9
Q1096-B
6.9
Q1096-C
9.1
Q1096-E
6.2
Q1097-B
5.9
Q1097-C
9.1
Q1097-E
5.3
Device/Pin #
Volts/Mode
