Section 07
ELECTRICAL SYSTEM
Sub-Section 04
(STARTING SYSTEM)
07-04-8
Step
: Retaining brush holder with a screwdriver
Step
: Align here
Align end frame notch with brush holder
notch/yoke protrusion.
STARTER INSTALLATION
Installation is essentially the reverse of removal
procedure. However, pay particular attention to
the following.
Make sure that starter and engine mating surfac-
es are free of debris. Serious trouble may arise if
starter is not properly aligned.
12,16, Screw
Apply Loctite 242 (blue) on threads and torque
starter screws to 22 N•m (16 lbf•ft).
17, Nut
Connect the RED battery cable to the starter and
torque nut to 6 N•m (53 lbf•
in
). Apply dielectric
grease on terminal and nut.
14,15, Screw and Teeth Washer
Apply Loctite 271 (red) on screw.
Connect BLACK cable to starter using flat washer,
teeth washer and screw. Torque screw to 22 N•m
(16 lbf•ft). Apply dielectric grease on terminal and
screw.
717 ENGINE SHOWN
Step
: Torque nut to 6 N•m (53 lbf•
in
)
Step
: Apply Loctite 271 on screw
Step
: Torque screw to 22 N•m (16 lbf•ft)
Step
: Apply dielectric grease
-
CAUTION
Make sure end frame fits perfectly on yoke.
F01H0UA
2
1
1
2
◆
WARNING
Always connect RED positive cable first then
BLACK negative cable last. Whenever con-
necting the RED positive cable to the starter
motor make sure the battery cables are dis-
connected to prevent electric shock.
F01H1JC
1
4
2
3
4
1
2
3
4
www.SeaDooManuals.net
Summary of Contents for 1997 GSI
