Thank you for purchasing a Sealey product. Manufactured to a high standard, this product will, if used according to these instructions,
and properly maintained, give you years of trouble free performance.
IMPORTANT:
PLEASE READ THESE INSTRUCTIONS CAREFULLY. NOTE THE SAFE OPERATIONAL REQUIREMENTS, WARNINGS & CAUTIONS. USE
THE PRODUCT CORRECTLY AND WITH CARE FOR THE PURPOSE FOR WHICH IT IS INTENDED. FAILURE TO DO SO MAY CAUSE DAMAGE AND/OR
PERSONAL INJURY AND WILL INVALIDATE THE WARRANTY. KEEP THESE INSTRUCTIONS SAFE FOR FUTURE USE.
AK3845.V2 Issue:1 - 03/11/17
Original Language Version
© Jack Sealey Limited
Refer to
Instructions
Wear eye
protection
1.
s
SAFETY
WARNING!
Ensure Health & Safety, local authority and general workshop practice regulations
are adhered to when using this equipment.
WARNING! DO NOT attempt to dismantle the strut under any circumstances until the
spring compressors are in place and the spring has been sufficiently compressed.
Familiarise yourself with the applications, limitations and potential hazards of this spring
compressor set.
Maintain the spring compressor set in good condition. Replace or repair damaged parts. Use
genuine parts only.
Unauthorised parts may be dangerous and will invalidate the warranty.
Keep the work area clean, uncluttered and ensure there is adequate lighting.
WARNING!
Wear approved safety eye protection (standard spectacles are not adequate).
Maintain correct balance and footing. Ensure the floor is not slippery and wear non-slip shoes.
Remove ill fitting clothes. Remove ties, watches, rings and other loose jewellery. Contain or tie
back long hair.
Wear appropriate protective clothing.
Keep children and unauthorised persons away from the working area.
Ensure jaws are correctly engaged on spring before commencing compression.
Ensure the jaws and the body of the compressor are correctly aligned at all times during
spring compression.
DANGER!
Stop compressing the spring before it becomes coil bound.
DO NOT
leave compressed spring unattended.
DO NOT
operate spring compressor set if parts are damaged or missing as this may cause failure and/or personal injury.
DO NOT
use the spring compressor set for a task it was not designed to perform.
DO NOT
allow untrained persons to use the spring compressor set.
DO NOT
operate spring compressor set if you are tired, or under the influence of alcohol, drugs or intoxicating medication.
WARNING!
DO NOT
use air tools with this product.
WARNING!
DO NOT
compress the spring to an extent where the coil windings touch.
WARNING!
DO NOT
compress the spring to an extent where the jaws touch.
When not in use clean and store the spring compressor set in a safe, dry, childproof location.
IMPORTANT:
These instructions are provided as a guide only. Always refer to the vehicle manufacturer’s service instructions, or a
proprietary manual, to establish the current procedure and data.
WARNING!
The warnings, cautions and instructions discussed in this instruction manual cannot cover all possible conditions
and situations that may occur. It must be understood that common sense and caution are factors which cannot be built into
this product, but must be applied by the operator.
2.
s
INTRODUCTION
Heavy-duty coil spring compressor with hardened steel body and force screw. Ensures smooth compression of spring.
3.
s
SPECIFICATION
Model No:. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .AK3845.V2
Drive: . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 17mm Hex
Maximum Jaw Opening:. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 280mm
Capacity Pair:. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1400kg
INSTRUCTIONS FOR:
COIL SPRING COMPRESSOR SET 2pc
HEAVY DUTY 1400kg/PAIR
MODEL NO:
AK3845.V2
