INSTRUCTIONS FOR
CABLE REEL SYSTEM RETRACTABLE 25mtr
1 X 230V SOCKET.
MODEL NO:
CRM251
Thank you for purchasing a Sealey product. Manufactured to a high standard, this product will, if used according to these
instructions, and properly maintained, give you years of trouble free performance.
IMPORTANT:
PLEASE READ THESE INSTRUCTIONS CAREFULLY. NOTE THE SAFE OPERATIONAL REQUIREMENTS, WARNINGS & CAUTIONS. USE
THE PRODUCT CORRECTLY AND WITH CARE FOR THE PURPOSE FOR WHICH IT IS INTENDED. FAILURE TO DO SO MAY CAUSE DAMAGE AND/OR
PERSONAL INJURY AND WILL INVALIDATE THE WARRANTY. KEEP THESE INSTRUCTIONS SAFE FOR FUTURE USE.
1. SAFETY
1.1. Electrical Safety
WARNING!
It is the user’s responsibility to check the following:
Check all electrical equipment and appliances to ensure that they are safe before using. Inspect power supply leads, plugs and
all electrical connections for wear and damage. Sealey recommend that an RCD (Residual Current Device) is used with all electrical
products. You may obtain an RCD by contacting your local Sealey dealer.
If used in the course of business duties, it must be maintained in a safe condition and routinely PAT (Portable Appliance Test) tested.
Electrical safety information, it is important that the following information is read and understood.
9
Ensure that the insulation on all cables and on the appliance is safe before connecting it to the power supply.
9
regularly inspect power supply cables and plugs for wear or damage and check all connections to ensure that they are secure.
9
Ensure that the voltage rating on the appliance suits the power supply to be used and that the plug is fitted with the correct fuse - see
fuse rating in these instructions.
8
DO NOT
pull or carry the appliance by the power cable.
8
DO NOT
pull the plug from the socket by the cable.
8
DO NOT
use worn or damaged cables, plugs or connectors. Ensure that any faulty item is repaired or replaced immediately by a
qualified electrician.
9
This product is fitted with a BS1363/A 13 Amp 3 pin plug.
If the cable or plug is damaged during use, switch off the electricity supply and remove from use.
Ensure that repairs are carried out by a qualified electrician.
Replace a damaged plug with a BS1363/A 13 Amp 3 pin plug. If in doubt contact a qualified electrician.
a) Connect the GREEN/YELLOW earth wire to the earth terminal ‘E’.
b) Connect the BROWN live wire to the live terminal ‘L’.
c) Connect the BLUE neutral wire to the neutral terminal ‘N’.
Ensure that the cable outer sheath extends inside the cable restraint and that the restraint is tight.
Sealey recommend that repairs are carried out by a qualified electrician.
1.2.
General Safety
Familiarise yourself with the application and limitations of the reel, as well as the specific hazards.
WARNING!
Isolate the reel from the electrical supply before connecting or disconnecting
equipment, servicing or performing any maintenance.
9
Maintain the reel in good condition (use an authorised service agent).
9
Replace or repair damaged parts. Use recommended parts only. Unauthorised parts may be dangerous and will invalidate the
warranty.
9
Locate and fix the reel in a suitable work area. DO NOT position in direct sunlight, or in areas of extreme temperature.
9
Keep extended cable away from heat, oil and sharp edges. Check cable for wear before each use and ensure all connections are
secure.
9
Maintain correct balance and footing. Ensure the floor is not slippery and wear non-slip shoes.
9
Keep children and unauthorised persons away from the work area.
8
DO NOT
allow the extended cable to trail through liquids.
8
DO NOT
trail the extended cable where it is likely to be a hazard to others.
8
DO NOT
allow vehicles or wheeled equipment to pass over the extended cable.
8
DO NOT
use the reel for any purpose other than that for which it is designed.
8
DO NOT
operate the reel when you are tired, under the influence of alcohol, drugs or intoxicating medication.
9
When not in use, switch off the electrical supply and retract cable into case. Store in a safe, dry location
WARNING! DO NOT
dismantle the reel casing, or attempt to remove the screws on the sides. To do so may result in damage to the
reel and/or personal injury and will invalidate the warranty. Internal maintenance, which will require the opening of the casing, must
only be undertaken by an authorised service agent.
WARNING!
Observe the wound and unwound capacities in the specifications below.
Recommended fuse rating
13 Amp
C
RM251 | Issue 2 20/07/17
Original Language Version
© Jack Sealey Limited
Refer to
instructions
Electrical
shock
hazard
