Gear Oil Replacement
Replace the gear oil after the initial 300 km(180 miles). Thereafter, replace oil again every 4 months
or 3000 km (1800 miles), whichever occurs first. Best done when gear oil is warm.
Do as Described Below for Replacement:
1)
Put the scooter on the center stand.
2)
Place an oil pan under the gear case
3)
Remove the oil filler bolt and drain plug to drain the oil
4)
Reinstall and tighten the drain plug
5)
Fill the gear case with oil.
6)
Reinstall the oil filler bolt.
7)
After replacing the gear oil, be sure to check for oil leakage.
Recommendation:
SAE 89W 90SF
NOTE: Do not let foreign materials enter the gear case. Be sure oil does not get on the back tire or
wheel.
Clean Air Filter
The air filter should be cleaned at the specified intervals. It should be cleaned more frequently if you
often ride in wet or dusty areas.
1)
Place the scooter on the center stand.
2)
Remove the left side panel by removing the
screws on it
3)
Remove the air filter cover by removing screws
on it.
4)
Pull out the air filter element and remove the
screws on it.
5)
Remove the air filter element and wash gently,
but thoroughly in solvent. Replace air filter if it
is damaged.
6)
Squeeze out excess solvent, and dry the air filter.
7)
Apply light oil to the entire surface of the air
cleaner and squeeze out the excess oil. It should
be damp, but not dripping.
8)
Reinstall the air filter and the air filter cover.
Recommend Oil:
Same as engine Oil.
NOTE: Drain the oil accumulated in the clear tube
after every 1,000 Km.
