30
(3) Air Filter Element Cleaning/Replacement
Clean
100 hours
Replace
Every 400 hours
Remove the air cleaner clips and cleaner cap.
Remove the outer element.
Clean or replace the element. Replace by performing the above procedures in reverse
order.
< Note >
Always be sure to turn the cleaner cap in the direction
indicated by the arrow.
Replace the elements earlier if using in an excessively
dusty location.
Do not add oil as this generator uses a dry element.
Clear foreign material by pinching the vacuator valve once
a week in normal operating conditions or daily if operating
in a location that is excessively dirty or dusty.
Wipe away any dirt or moisture that has adhered to the
parts.
Never touch the elements for any reason except
cleaning.
Element part no.: Outer Element 59700-26112
Inner Element 55231-26151
(Kubota part no.)
Cleaning the air filter element
If dry dust is adhering : Blow compressed air from
inside the element.
If carbon or oil is adhering : Replace with new
parts.
(4) Draining Water from the Water Separator
Check
Daily
Clean
Every 200 hours
Drain water when the float (red) inside the cup is at the
water draining position.
Close the fuel valve.
Loosen the faucet and then loosen the air bleeder
plug.
After water has been drained, tighten the faucet and
air bleeder plug.
If foreign material is adhering to the gauze filter in the
cup, remove the cup, float and gauze filter, and clean
by blowing compressed air from the inside of the
gauze filter.
Reassemble the gauze filter, cup and float to their original locations.
< Note >
When attaching the cup, check that there is no foreign material adhering to the O-ring.
1
2
3
Outer Element
Inner Element
Vacuator
Valve
Air Cleaner Cap
Clip
Air Cleaner Cap
Air Cleaner
Air
Bleeder
Plug
Close
Fuel
Valve
Cup
Gauze Filter
Water Drain Level
Float (Red)
Open
Faucet
1
2
3
4
5
Summary of Contents for DG50MK-P
