TM
Page 50
December 2007
ZB12032
Section 2 - Operation
Procedures
B
C
0
4
8
12
16
20
0
-2
4
8
12
16
20
24
28
32
72°
-8°
0°
10°
20°
30°
40°
50°
60°
B
C
D
E
F
ft
ft
0
(1.2)
(2.4)
(3.7)
(4.9)
(6.1)
(m)
0
(-0.6)
(1.2)
(2.4)
(3.7)
(4.9)
(6.1)
(7.3)
(8.5)
(9.8)
(m)
M
O
O
B
FORWARD REACH
FACE OF TIRE
LOAD RATINGS COMPLY
WITH ANSI/ITSDF B56.6-
2005 STABILITY
REQUIREMENTS FOR
ROUGH TERRAIN
FORKLIFTS.
THIS CHART COVERS PIPE GRAPPLER ATTACHMENT
CAPACITY CHART MODEL ZB12032
NO LOAD
BEHIND FRONT
FACE OF TIRE
ALL DIM. ARE U.S.A.
CUSTOMARY UNITS,
DIM. IN (x) S.I. UNITS
HEIGHT
RATED CAPACITY AT 24"
LOAD CENTRE
N
O
I
S
N
E
T
X
E
NO LIFT
ZONE
2.11 Use of the Capacity Chart
The capacity chart is located in the operator’s cab.
It is used to determine maximum load capacity for
telehandlers equipped with different attachment
combinations.
To properly use the capacity chart, the operator must
first determine the following:
1.
Ensure the telehandler is on a firm, level surface
with properly inflated tires, and the capacity
chart is for the specific telehandler model and
attachment.
2.
Determine the weight of the load to be lifted
3.
Determine the height where the load is to be
picked or placed.
4.
Determine the reach where the load is to be picked
or placed.
5.
The maximum capacity is determined by the
intersection lines between height and reach on
the capacity chart. If the intersection of the lines
occurs at a division between capacity zones,
the smaller of the two capacity values must be
used.
NOTE
The weight of the load must be equal to or
less than the number in the capacity zone.
impORTANT
The telehandler is rated for 12,000 lb.,
but 2000 lb. is consumed by the weight
of the grappler. Therefore, the telehandler
capacity will be 10,000 lb.
wARNiNG
When handling load, ensure that boom
extension indicator and boom angle
indicator remain within previously
determined/calculated capacity zone.
Capacity Chart
Telehandler
Model
Telehandler
Attachment
Boom
Angle
Boom
Extension
NO LIFT ZONE
SAMPLE ONL
Y - USE CHART IN CAB
Figure 2-9 Sample Capacity Chart
Boom Angle
Indicator
Boom Extension
Indicator
Reach
Height
Figure 2-10 Boom Indicators
Summary of Contents for ZB12032
