SECONDARY TRANSMISSION SYSTEM 9 - 9
REASSEMBLY
o
Install pressure plate
# 5
inside the cog sprocket
# 1
using the small Allen screws
# 8
. Use loctite 243 on the
Allen screw and torque to
10 N-m (89 lbf-in).
o
Reassemble the torque limiter as shown in the exploded
view on page 9-3.
o
Once the pressure plates
# 4
and the friction plates
# 6
are properly installed, hand tighten the threaded
aluminum disc
# 3
until it stops; then loosen by a ½ turn.
o
To complete reassembly, tighten the 6 Allen bolts
# 7
in
a criss-cross pattern to a torque of
6 N-m (55 lbf-in).
INSTALLATION
Install the torque limiter as described in the previous section on
installation of the secondary drive cog belt.
o
Lift up and immobilize the rear of the vehicle and place it
on a mechanical support.
◆
WARNING
Make sure that the track is free of anything that could be
projected out of its rotation field. Make sure that no one is
near the vehicle.
o
Have the vehicle accelerate at low speed (maximum 30
km/h or 20 mi/h) and apply the brake. Repeat 5 times.
o
Ensure that the torque of the 6 Allen bolts
# 7
is still at
6 N-m (55 lbf-in).
◆
WARNING
After approximately 10 hours of use, it is necessary to
verify the torque of the 6 allen head screws ( part # 7 ) of
the torque limiter. The required torque for normal
operation is 6 N-m ( 55 lbf-in ).
Summary of Contents for 600HO
