1-855-SWTOOLS — www.southwire.com
1-855-SWTOOLS — www.southwire.com
• Do not operate in explosive atmosphere.
• Always disconnect the cable reel roller before servicing.
• Always plug into grounded receptacle that is GFCI protected.
• Do not alter this cable reel roller. Doing so will void the warranty. Guards
and safety features are provided for your protection.
• Do not use extension cord longer than 100 ft. Extension cord should be
10-gauge wire with ground.
• When operating, operator should stand to the side of the cable reel roller
and out of the path of the cable.
• DO NOT use a wooden reel in junction with this reel roller. Steel
Reels ONLY.
• RR-SW45 should only be stacked with using 2.5” rigid conduit
• When stacking, the units should only be stacked 3 units high.
• Do not stack on unlevel ground
• Minimum operating electricity requirements:
220 Volts single phase, 30 Amps, 6600 Watts
Generator > 30 Amps
WARNING- Entanglement Hazard
• Do not operate this tool while wearing loose-fitting clothing. Retain
long hair.
• Keep hands away from the rollers while the unit is active
• Operator should stand to the side of the unit while the roller is in
operation
WARNING- Tool Use Hazards
• Use this tool for manufacture’s intended purpose only. Use other than that
which is described in this manual can result in injury or property damage.
• Inspect all aspects of the pull to ensure safety.
• Only qualified personnel should use the payoff equipment.
• Do not use the reel roller for any other purpose than what it
is intended for.
CAUTION
Read and understand all the instructions and safety information in this
manual before operating or servicing this tool. FAILURE TO OBSERVE THESE
WARNINGS COULD RESULT IN SEVERE INJURY OR DEATH.
CAUTION
• Do not use if any parts are damaged as this can cause an unsafe
condition and lead to tool malfunction or failure.
• If tool is in disrepair, DO NOT USE. Have tool serviced at an
Authorized Southwire Repair Center.
FAILURE TO OBSERVE THESE WARNINGS COULD RESULT IN SEVERE INJURY
OR DEATH.
DESCRIPTION OF OPERATION
The Southwire
®
45K Reel Roller is a heavy duty, all welded reel roller. The
Reel Rollers intended purpose and operation is solely for paying off wire
that has been allocated on a STEEL REEL. One should never attempt to
operate with a wooden reel. In doing so may result in an injury. The unit
has been designed to be a long lasting, well-functioning piece of equipment
that can be stacked for storage purposes. To properly stack, the unit should
utilize 2.5” Rigid conduit and only stack 3 total units high. All units should
never be stacked on unlevel ground.
