Spraying Systems Co TankJet M60, Operation & Maintenance Instructions Manual

26

TJM60AG

 T

ank

 Cleaner

ǀ    

08/07/2017

Mode of Failure 

Description

Preventative or Corrective Actions

Nozzle head on  

TJM60AG tank cleaner 

does not rotate and  

shear pin is not broken .

Possible cause is that the air motor is not 

rotating.

First, check to see if minimum requirement 

of ¼ inside diameter hose is connected 

to air inlet connection near trigger valve 

on TJM60AG tank cleaner . If the hose is 

under sized it must be replaced with a hose 

meeting minimum size requirements.

If hose size is correct the motor may have 

minor amount of dirt or corrosion .

Remove air motor from gear box on 

TJM60AG tank cleaner and disconnect 

air hose. Leave muffler on air motor. Then 

apply a few drops of light oil (not grease)) 

into air motor . Then free up air motor by 

rotating shaft by hand. Then connect air 

hose to air motor and try running air motor 

at a low pressure of 10 psi . If motor runs 

freely, reassemble air motor to TJM60AG 

tank cleaner .

If motor still does not run freely, motor may 

require  major  cleaning.  Please  refer  to 

included Gast Air motor owner’s manual . 

SPRAYING SYSTEMS CO .

®

 WARRANTY

Seller  warrants  that  its  products  will  conform  to  and  perform  in  accordance  with  the  products’  specifications.  Seller 

warrants that the products do not infringe upon any copyright, patent or trademark. THE FOREGOING WARRANTIES 

ARE IN LIEU OF ALL OTHER WARRANTIES, EXPRESSED OR IMPLIED, INCLUDING, BUT NOT LIMITED TO, THOSE 

CONCERNING MERCHANTABILITY AND FITNESS FOR A PARTICULAR PURPOSE.

Because of the difficulty of ascertaining and measuring damages hereunder, it is agreed that, except for claims for bodily 

injury, Seller’s liability to the Buyer or any third party, for any losses or damages, whether direct or otherwise, arising out 

of the purchase of product from Seller by Buyer shall not exceed the total amount billed and billable to the Buyer for the 

product hereunder. IN NO EVENT WILL SELLER BE LIABLE FOR ANY LOSS OF PROFITS OR OTHER SPECIAL OR 

CONSEQUENTIAL DAMAGES, EVEN IF SELLER HAS BEEN ADVISED OF THE POSSIBILITY OF SUCH DAMAGES.