1.
IMPORTANT SAFETY INSTRUCTIONS
1.1 Overview
Thoroughly read this operation manual before operating the generator set. It contains important instructions
that should be followed during operation and maintenance. Safe operation and top performance can only be
achieved when equipment is properly operated and maintained. The owners and operators of the generator
set are solely responsible for it’s safe operation.
Generator set operation, maintenance, and installation must comply with all applicable local regulations.
Electricity, fuel, exhaust, moving parts and batteries present hazards which can result in severe personal injury
or death. Only trained and experienced personnel with knowledge of fuels, electricity, and machinery hazards
should perform generator set installation or adjustment procedures; or remove, dismantle the generator set.
1.2 Safety symbols
The following symbols are applied in the manual indicate potentially hazardous conditions to the
operators, service personnel, or the equipment.
DANGER
Indicates a hazardous situation that, if not avoided, will result in death or serious injury.
WARNING
Indicates a hazardous situation that, if not avoided, could result in death or serious injury.
CAUTION
Indicates a hazardous situation that, if not avoided, could result in minor or moderate injury.
NOTE
Indicates information considered important, but not hazard-related (e.g., messages relating to property damage).
1.3. General Safety Precautions
To generator set operators
WARNING
•
Do not operate the generator when fatigued, or after consuming any alcohol or drug.
•
Wear suitable clothing when operating the generator. Loose clothing is easily caught in the moving parts and
cause serious injury.
•
Operators must be thoroughly trained before operating the unit.
•
Only suitable trained and experienced service personnel can perform
•
electrical and/or mechanical service.
•
Do not allow any unauthorized personnel nearby the running generator set.
•
Keep the generator set out of the reach of the children and pets.
•
Pay attention to any abnormalities when the generator is running such as vibration, noise, exhaust smoke color
and leaks. Shut down the generator immediately and troubleshoot before restarting the generator set.
Fuel and Fumes Are Flammable
WARNING
•
Do not fill fuel tanks while the engine is running unless the tanks are outside the engine
compartment. Fuel contact with hot engine or exhaust is a potential fire hazard.
•
Do not permit any flame, cigarette, pilot light, spark, arcing equipment, or other ignition source
near the generator set or fuel tank.
•
Fuel pipes must be adequately secured and free of leaks. Fuel connection at the engine should
be made with an approved flexible line. Do not use copper piping on flexible pipes.
•
Flammable vapor can cause an engine to over speed and become difficult to stop, resulting in
possible fire, explosion, severe personal injury or death. Do not operate the unit in flammable
and explosive environments.
•
Any spillage that occurs during fueling, oil top-off, or oil change must be cleaned up before
starting the generator set.
Ver. 3/Rev. 1; Data: 03.02.2022;
30
Summary of Contents for YDE6500E
