Section 5
MAINTENANCE
34
5.10 TROUBLESHOOTING GUIDE (CONTINUED)
SYMPTOM
PROBABLE CAUSE
REMEDY
FLASH CODE: FOUR FLASHES
No/Low fuel
Check fuel level and add fuel if necessary.
Plugged fuel filter
Replace and clean as required.
Plugged air filter
Replace and clean as required.
Water/Dirt in fuel and/or fuel filter
Drain water from fuel water separators on fuel filters
Siphon water from fuel tank and clean fuel tank it.
necessary.
COMPRESSOR WILL NOT
For compressors with idle warm---up controls,
BUILD UP FULL DISCHARGE
switch toggle to “run” for full operation.
PRESSURE
Air Demand Is Too Great.
Check service lines for leaks or open valves.
Dirty Air Filter
Check the filter indicator and change element
if required.
Defective Pressure Regulator
Check diaphragm and replace if necessary
(kit available).
Defective Idle Warm---up Control
Replace control.
IMPROPER UNLOADING WITH AN
EXCESSIVE PRESSURE BUILD---UP
CAUSING PRESSURE RELIEF VALVE
TO OPEN
Pressure Regulating Valve Is Set
Readjust.
Too High
Leak In Control System Causing
Check control lines.
Loss Of Pressure Signal
Defective pressure regulating valve;
repair valve (kit available).
Inlet Valve Jammed
Free or replace valve.
FLASH CODE: FIVE FLASHES (option) No/low fuel
Check fuel level & add fuel if necessary.
IMPROPER UNLOADING WITH AN
EXCESSIVE PRESSURE BUILD---UP
CAUSING PRESSURE RELIEF VALVE
TO OPEN (continued)
Restriction In The Control System
Check all control lines and components.
Ice and/or other contaminants could cause
.
Defective Pressure Relief Valve
Replace pressure relief valve.
Opening At Too Low Of Pressure
Defective Pressure Regulator
Check diaphragm and replace if necessary
(kit available).
INSUFFICIENT AIR DELIVERY
Engage Idle Warm---up Control In “Run”
Position For Full Compressor Operation.
Plugged Air Filter
Replace.
Plugged Air/Fluid Separator
Replace separator element and also change
compressor fluid and fluid filter at this time.
Defective Pressure Regulator
Adjust or repair.
Engine Speed Too Low
Readjust engine speed.
Defective Idle Warm---up Control
Replace control.
Summary of Contents for 185H
