Replacement of Fuel Filter
1.
2.
3.
4.
5.
Shut down petcock.
Remove the filter by rotating it in counter-clockwise
direction by hand or special wrench.
Take new filter and check it for proper seating of gasket.
Apply clean engine oil to gasket on the new fuel filter.
Install fuel filter, when the filter gasket contacts the
mounting surface of filter, tighten the filter and ensure that
there is no leakage.
After changing the fuel filter, air must be removed from the
system:
Air Bleeding of Fuel System
1.
2.
3.
4.
5.
Switch ON the ignition key to start the electric pump until
completion of air bleeding process.
Loosen the vent plug (A) at top of fuel filter body.
Tighten the vent plug (A) after bubble free fuel flows from
the air vent plug hole.
Loosen the vent plug (B) of FIP and allow the air to flow
out from the system.
Tighten the vent plug (B) after bubble free fuel flows from
the return valve.
Radiator
Checking Coolant Level in Radiator
Fuel Filter
A
B
2
1
Slowly open the radiator cap (1) up to the safety catch (about
1/3 turn). Wait to allow the steam to escape. Continue
opening the cap, press it down firmly to release the safety
catch. The level of coolant should just touch the tab located in
the filling spout.
In sub zero temperature climate conditions use
Glysantin G40 antifreeze agent along with water in
following ratio:
If the level has dropped, check the entire cooling system for
leakage (radiator, hoses etc.) If there is no leakage, top up the
coolant up to the maximum mark.
Coolant is a mixture of water and anti rusting / anti freezing
agent in a recommended ratio.
Fill the reserve tank (2) with coolant up to the full line mark for
coolant t
.
op up
Temperature
0
0
Range F [ C]
Antifreeze (%)
32 to
26.6
[0 to -3]
10
20
30
40
50
60
26.6 to
17.6 [-3
to -8]
17.6 to
3.2 [-8
to -16 ]
-16 to -
25 [3.2
to -13 ]
-13 to
34.6 [-25
to -37]
-34.6 to -
67 [-37
to -55]
Summary of Contents for TX25H
