8-24 CHASSIS
BRAKE FLUID REPLACEMENT
• Place the vehicle on level ground and keep the handlebar
straight.
• Remove the master cylinder reservoir cap and diaphragm.
• Suck up the old brake fluid as much as possible.
• Fill the reservoir with new brake fluid.
)
Specification and classification: DOT 4
• Connect a clear hose to the air bleeder valve and insert the
other end of the hose into a receptacle.
• Loosen the air bleeder valve and pump the brake lever until
the old brake fluid is completely out of the brake system.
• Close the air bleeder valve and disconnect the clear hose. Fill
the reservoir with new brake fluid to the upper end of the
inspection window.
$
BRAKE CALIPER REMOVAL AND
DISASSEMBLY
• Remove the front wheels. (
!
8-13)
• Disconnect the brake hoses from the brake caliper by remov-
ing the brake hose union bolt
1
and allow the brake fluid to
drain into a suitable receptacle.
• Remove the brake caliper by removing the brake caliper
mounting bolts
2
.
• Remove the brake pads. (
!
8-23)
'
* Never reuse the brake fluid left over from previous
servicing or which has been stored for long periods
of time.
* Bleed air from the brake system. (
!
2-24)
Brake fluid, if it leaks, will interfere with safe running
and discolor painted surfaces. Check the brake hose
and hose joints for cracks and oil leakage.
Summary of Contents for LT-A700X 2004
