Tanco Autowrap -
VariAuto
Operator’s Manual
10
5. BALE WRAPPING
For long-term storage, or when the grass is wet when it is wrapped, the bale should have 90-100 µ plastic (six layers) and the same amount of overlap. If thinner plastic is used, more
layers should be applied. If it is very hot the plastic will be stretched further, and more layers should be applied. It is better to have slightly too much than too little plastic on the bale.
From experience, light colored plastic absorbs less heat, and this tends to improve feed quality.
5.5. Storage Location
Care should be taken in finding a suitable location for the storage of bales. The storage location should preferably be prepared before the bales are laid out. An elevation close to well
drained roads is recommended. If the wrapped bales are simply placed on stubble there is a danger of the plastic being pierced. A tarpaulin or a thin layer of sand should therefore be laid
where the bales are to be stored over the winter.
Bales should be stored in the shade if possible. This reduces the danger of air leakage in the bales. A bale which is stored in sunlight will undergo fluctuating temperatures and therefore
“pumps in” a great deal of air in comparison to a bale stored in the shade. According to “Teknik for Lantbruket” [Technology for Agriculture] in Sweden, a bale stored in the shade has only
40% of the air leakage of a bale which is stored in sunlight.
5.6. Stacking / Protection
If bales are hard and well formed, they can be stacked vertically, but loose and misshapen bales with low dry matter should not be stacked higher than one layer, as this could easily cause
deformity and the danger of runoff will be increased.
Bales can also be stored on their ends. The plastic coverage is thicker here, providing greater protection against piercing. Bales should be covered with a tarpaulin or a fine-mesh net to
protect against birds and small rodents. If the plastic is pierced, it must be sealed with weatherproof, hard-wearing tape, preferably under the outermost layer of plastic. Ensure that the
hole is adequately sealed.
5.7. For Best Wrapping Results
1. Harvest the grass early.
2. Ensure the grass is dried out to 30-40% solid content. If there is a danger of rain, bale and wrap the grass anyway.
3. Take care not to mix any soil in with the grass.
4. Use a baler that produces even, firm bales. Bales 1.2mtrs in width and with a diameter of 1.2-1.5mtrs are preferred sizes.
5. Wrap the bales as soon after baling as possible; never more than two hours after.
6. Use a good plastic type, applying six layers of plastic. This removes the need to use preservatives.
7. Store bales in the shade to reduce the danger of air leakage.
Summary of Contents for S200 VariAuto
