VERTICAL TOWED MIXER - TWO AUGERS
MV-30D SERIES
MAINTENANCE INSTRUCTIONS
ATTENTION. ALWAYS DISCONNECT the power take-off and REMOVE tractor keys
before adjusting, lubricating or performing any maintenance on the mixer.
NOT PAYING ATTENTION MAY CAUSE SERIOUS PERSONAL INJURY OR DEATH.
- When a replacement of parts are required, you must use genuine factory parts to
restore the equipment, following the specifications of the original parts. TATOMA will
not assume any responsibility for the use of unauthorized parts and / or accessories
that may cause damage as a result of their use.
- If the equipment has been altered in any way, from its original design, TATOMA will
not accept any responsibility for warranty or possible injuries.
LUBRICATION:
- Disconnect the transmission and turn off the power before lubricating the machine.
- DO NOT wear loose clothing that can get caught in moving parts.
- Grease the drive shafts and universal joints every 8 hours of operation.
- Planetary / 2 speed gear box: After the first 500 hours of operation, drain the initial
oil preferably when the box is hot. For an effective oil change, the unit should be
washed with a detergent liquid, preferably that recommended by the lubricant
supplier and refilled with clean oil. Thereafter the oil must be changed every 2000
hours or 12 months, whichever comes first. Fill the gearbox with 80W-90 synthetic
lubricant.
- Recommendation: It is recommended to check the gearbox oil level at least once a
month. If after the review you must add more than 10% of the total capacity, check for
oil leaks.
- Gearbox housing temperature: under normal operating conditions, the temperature
of the outer casing of the gearbox must not exceed 175 ° F (80 ° C).
Tatoma Ag Equipments Corp. Located in Colcord, OK. Phone (918) 422-4271
- 22 -
