Maintenance, Service and Repair
Page 3
Troubleshooting Guide
Symptom
Probable Cause
Steering Pulls in One Direction
Front End Out of Alignment
Low Tire Pressure
Hard Steering
Dry Lube Points in Steering Linkage
Damaged Fork Barings/Ball Joint
Low Tire Pressure
Excessive Steering Play
Worn Ball Joints
Mis-Adjusted or Worn Steering Gear
Loose Steering Linkage
Lack of Power or Slow Operation
Brakes or Parking Brakes Dragging
Batteries Discharged or Defective
Worn Drive Gears
Front End Out of Alignment
Defective Speed Control
Abnormal Noise
Worn Drive Gears or Bearings
Worn Front /Rear Axle Bearings
Loose Lug Nuts
Motor Bearings Worn
Oil Leak in Rear Bearing Area
Rear Wheel Bearing and/or Gasket Failed
Drive Over Filled
Brake Pedal Soft or Spongy
Air in Brake Lines
Brake Pedal Low
Brake Worn (1/16" Wear Limit)
Brake Fluid Low
Brakes Out of Adjustment
Braking Power Low
Brake Worn (1/16" Wear Limit)
Brake Pads Contaminated with Fluid
Brake Pedal Linkage Binding
Brakes Out of Adjustment
Air in Brake Lines
Note: This list is provided as a guide only. It is not all inclusive of causes that may result in a specific
symptom.
Summary of Contents for MB-238-00
