5.2 ABOUT THE STOVE
smoke
pipe
handle
window
with outer
ring
cladding
base
firing
chamber
door
firing
chamber
grate
ash box
5.3.2 VENT PIPE AND VEN-
TILATING SYSTEM
Extractor hoods and ventilating sys-
tems can affect the operation of your
A
A
A
B
E
F
A
A
A
B
E
F
4.3 GENERAL SAFETY
INSTRUCTIONS
• Never leave children alone or unat-
tended at a burning fireplace.
• Teach your children how to behave
properly and operate safely the fire-
place.
• Every stove gets hot when fired: risk
of burning!
• Avoid touching the outside surfaces
when the stove is operating.
• Do not burn refuse or painted wood.
• Dispose of the ashes only after they
have cooled completely.
• Inform your specialised dealer with-
out delay of defect gaskets.
• Observe the information in our oper-
ating instructions and make a proac-
tive contribution to fire prevention
and the protection of our environ-
ment.
4.4 CHIMNEY SAFETY
INSTRUCTIONS
The condition and functionality of
your chimneys must be inspected by
a chimney sweep or specialist before
the Tonwerk storage heating stove is
installed.
This will provide the optimal condi-
tions for trouble-free heating.
4.2 SAFETY DISTANCES TO SWIVELLING TONWERK STORAGE
HEATING STOVES: T-EYE
Safety distance A
The side and rear panels must be no closer
than 10 cm to flammable materials
Safety distance B
Smoke pipes must be no closer than 20 cm
to flammable materials
Safety distance C+D
Flammable floor materials must be
no closer than 50 cm to the front and
30 cm to the sides.
Safety distance E
A minimum distance of 80 cm applies to
the whole swivelling range
Safety distance F
The minimum distance from the ceiling
is 50 cm
Safety distance A
The side and rear panels must be no closer
than 10 cm to flammable materials
Safety distance B
Smoke pipes must be no closer than 20 cm
to flammable materials
Safety distance C + D
Flammable floor materials must be
no closer than 50 cm to the front and
30 cm to the sides
Safety distance E
Firing chamber apertures must be no
closer than 80 cm to flammable mate-
rials within the radiation zone
Safety distance F
The minimum distance from the ceiling
is 50 cm
4.1 SAFETY DISTANCES TO FIXED TONWERK STORAGE
HEATING STOVES: T-EYE
4. FIRE PROTECTION
The national and European standards, the local and building legislation, and the
fire safety terms and conditions must be observed without condition.
Your chimney sweep or Tonwerk partner company will be pleased to inform you.
5. OPERATING INSTRUCTIONS
5.1 BEFORE FIRING THE
STOVE FOR THE FIRST
TIME
Dear Customer,
You have now been instructed by one
of our specialised dealers on how
to fire your Tonwerk storage heating
stove.
In these operating instructions we
wish to set down each step that you
must take if you are to encounter no
problems when operating your Ton-
werk storage heating stove.
Read through these operating instruc-
tions carefully and keep them in a safe
place. Your specialised dealer will be
pleased to assist you with any ques-
tions you may have.
5.3.1 WHEN THE STOVEPIPE
PAINT DRIES
When the stove is fired for the first few
times the paint on the stovepipe emits
an odour when it dries.
Make sure that the combustion cham-
ber is completely filled. The Tonwerk
storage heating stove then reaches
its optimal operating temperature and
the paint dries faster.
Also make sure the room is well venti-
lated during this phase.
5.3 GENERAL INFORMATION
5.3.3 HEATING IN THE
TRANSITION TIME
AND IN DIFFICULT
CONDITIONS
In damp or foggy weather, at outdoor
temperatures from 15 °C, and during
the transition time you are advised to
light a pilot fire before firing the stove
proper. This serves to displace the
cold, heavy air in the chimney and to
create the right conditions for the opti-
mal extraction of smoke.
C
D
D
C
D
D
5.3.4 PREPARATIONS FOR
FIRING
Have ready an adequate supply of
chopped firewood, ecofriendly lighting
aids, and kindling. You are best storing
the wood in a warm room for a number
of days before firing.
Tonwerk storage heating stove.
Please make sure that there is ade-
quate incoming air for multiple instal-
lations.
This pilot fire is lit with paper in the
chimney’s inspection aperture until ex-
traction is assured.
6. FIRING THE STOVE
To open –
push the handle to the back (1)
To close –
pull the handle to the front (2)
IMPORTANT
The lock must
engage!
2
1
Design: GAAN Gabriela Vetsch, André Riemens
