Fuel System Service
Priming Fuel System
1. Stop the engine. Unlatch and raise the hood
2. Fill the fuel tank.
3. Install a 3/16" hose over bleed screw. Put other end
of hose into a container to catch fuel (Fig. 38).
4. Pump priming plunger until resistance is felt. Try to
start engine. If engine does not start, go to step 5.
5.Loosen bleed screw a few turns. Pump priming
plunger until a steady stream of fuel comes out of hole
in bleed screw. When fuel stops foaming, tighten bleed
screw during down stroke of priming plunger. Wipe up
any spilled fuel.
NOTE: It may be necessary to bleed air out of the fuel
line, between the fuel filter/water separator and the
injection pump. To do this, loosen the fitting on the
injection pump (Fig. 39) and pump priming plunger until
a steady stream of fuel comes out of fitting. When fuel
stops foaming, tighten the fitting during the down stroke
of the priming plunger. Wipe up any spilled fuel.
NOTE: The high pressure fuel system is self-bleeding.
It is not necessary to open the high pressure lines.
Figure 38
1. Primer plunger
2. Bleed screw
Figure 39
1. Injection pump fitting
Injection Pump Removal
(See Injection Pump Removal in the Engine Overhaul
section.)
Injection Pump Repair
NOTE: If the pump needs to be inspected or repaired it
is recommended that it be done by an authorized CAV
Lucas ROTO DIESEL service dealer - especially during
the warranty period. Repairs by non-authorized dealers
WILL void the pump warranty.
IMPORTANT: Clean the injection pump and the area
around the injection pump before removing or serv-
icing it. DO NOT spray water onto a hot injection
pump.
1
2
1
Engin
e
Reelmaster 6500-D/6700-D
Page 3 - 33
Engine
Summary of Contents for REELMASTER 6500 D
