WARNING
This conversion kit
shall be installed by a
qualifi ed service agency
in accordance with the
manufacturer's instructions
and all applicable codes
and requirements of
the authority having
jurisdiction.
If the information in these
instructions is not followed
exactly, a fi re, explosion
or production of carbon
monoxide may result
causing property damage,
personal injury or loss of
life.
The qualifi ed service
agency is responsible for
the proper installation of
this kit.
The installation is not
proper and complete
until the operation of the
converted appliance is
checked as specifi ed in the
manufacturer's instructions
supplied with the kit.
If the unit is to be used on propane
convert as follows using the compo-
nents supplied with the burner:
CAUTION
The gas supply and electrical power
shall be shut off before proceeding
with the conversion.
Note:
Factory supplied components must be used to
ensure correct input. After conversion confi rm
proper manifold pressure.
1.
If installed remove the sand and rocks
from the burners.
2.
If installed remove the burner tray.
(8 screws)(Fig. #79)
3.
Remove burners by gently lifting up
the end and disengaging from the
orifi ce.
4.
Using a 1/2” wrench, undo the natu-
ral gas burner orifi ce, (marked
#32
).
Apply a small amount of pipe joint
compound to the threads of the pro-
pane burner orifi ce (marked
#51
) to
ensure a good seal, before screwing
it into the manifold.
Loosen the primary air shutter
screw, open shutter to give a gap of
13/64” (0.2”) and re-tighten. Repeat
on other burner. (Fig. #81)
5.
With a 7/16” wrench loosen the pilot
head on the pilot assembly. (Fig. #82)
CONVERSION LABEL (5052.52089)
MINIMUM RATE SCREW (5005.16)
MAIN BURNER
(#51) ORIFICES (5022.94)
PROPANE CONVERSION KIT
Date:
______________________
By / Par:
___________________
LP GAS/
DU GAZ LP
12.5 in/wc /12.5 po/c.e.
(3.11 kPa)
13.9 in/wc / 13.9 po/c.e.
(3.45 kPa)
11.0 in/wc / 11.0 po/c.e.
(2.74 kPa)
#51
Max.: 61,000Btu (17.8kw)
Min.: 39,000Btu (11.5kw)
120412 6-WS54ST 5052.52089
Kit # TCWS.54STLP for use with model: Pour
utilise avec du modèle:
TCWS54ST
This appliance was converted
t o P R O PA N E G A S w i t h
this kit on this date by the
organization which accepts
the responsibility that this
conversion has been properly
made. / Cet appariel etair
converter au gaz LP par l’emploi
de la trousse de conversion par
une organization qui accepte
la responsibilité pour une
installation en bon état.
ORIFICES
PILOT HEAD
Fig #80
Fig #82
Fig #79
Fig #81
Fig #78
Propane Conversion
44
TCWS.54CSTE 110712-72
Summary of Contents for TCWS54ST SERIES D
Page 70: ...70 TCWS 54CSTE 110712 72 ...
