I. THE SERIAL TAG
The serial tag is a permanently affixed
sticker on which is recorded vital electrical
and refrigeration data about your Traulsen
product, as well as the model and serial
number. This tag is located on the upper
right interior side wall of all air curtain
models.
TABLE OF CONTENTS
I. THE SERIAL TAG
Page 1
II. RECEIPT INSPECTION
Page 2
III. INSTALLATION
a- Location
Page 2
b- Packaging
Page 2
c- Clearance
Page 2
d- Wiring Diagram
Page 2
e- Cord & Plug
Page 2
f- Power Supply
Page 2
IV. INTENDED USE
a- Overview
Page 3
b- Typical Operating Parameters
Page 3
c- Suggested Pan Sizing
Page 3
d- Product Unloading
Page 3
V. PRODUCT FEATURES
a- Casters
Page 3
b- Grips & Handles
Page 3
c- Electronic Control
Page 3
d- On Demand Defrost
Page 3
e- Condensate Evaporator
Page 4
f- Tray Slides
Page 4
g- Wrap Around Bumper
Page 4
VI. ELECTRONIC CONTROLLER
a- Control Overview
Page 4
b- Control Feature: ON/OFF
Page 4
c- Control Feature: On Light
Page 4
d- Control Feature: Cycle Light
Page 4
e- Control Feature: Temp Recall
Page 4
Open Door Alarm
Page 4
f- Control Feature: On Demand Defrost Page 5
g- Control Feature: 2-Stage Thermostat Page 5
h- General Operating Instructions
Page 5
VII. CARE & MAINTENANCE
a- Cleaning The Condenser
Page 6
b- Cleaning The Exterior
Page 6
c- Cleaning The Interior
Page 6
VIII. OTHER
a- Service Information
Page 6
b- Spare Parts
Page 6
c- Warranty Registration
Page 6
IX. TROUBLESHOOTING GUIDE
Page 7-9
X. WIRING DIAGRAM
Page 10
XI. WARRANTY INFORMATION
Page 11
XII. INDEX
Page 12
MODEL NO.
SERIAL NO.
DESIGN PRESSURE
HIGH SIDE LOW SIDE
REFRIGERANT AMOUNT
VOLTS
AMPS
WATTS
HZ
CODE
UL
®
UL
®
C
LISTED
17YO
FOR SERVICE: 815-459-7500
4401 Blue Mound Road, Fort Worth TX 76106
COMMERCIAL REFRIGERATION
AND/OR
FREEZER
READING THE SERIAL TAG
• Serial Number = The permanent ID# of your Traulsen
• Model Number = The model # of your Traulsen
• Volts = Voltage
• Amps = Total Current = Maximum amp draw
• Watts = Total Maximum Wattage
• Hz = Cycle
• Refrigerant = Refrigerant type used
• Design Pressure = High & low side operating
pressures and refrigerant charge
• Agency Labels = Designates agency listings
-1-
TABLE OF CONTENTS
I. THE SERIAL TAG
Page 1
VI. ELECTRONIC CONTROLLER
II. RECEIPT INSPECTION
Page 2
a- Control Overview
Page 4
III. INSTALLATION
b- Control Feature: ON/OFF
Page 4
a- Location
Page 2
c- Control Feature: On Light
Page 4
b- Packaging
Page 2
d- Control Feature: Cycle Light
Page 4
c- Clearance
Page 2
e- Control Feature: Temp Recall
Page 4
d-
Wiring Diagram
Page 2
Open Door Alarm Page 4
e-
Cord & Plug
Page 2
f- Control Feature: On Demand Defrost Page 5
f- Power Supply
Page 2
g- Control Feature: 2-Stage Thermostat Page 5
IV. INTENDED USE
h- General Operating Instructions Page 5
a- Overview
Page 3
VII. CARE & MAINTENANCE
b- Typical Operating Parameters Page 3
a- Cleaning The Condenser
Page 6
c- Suggested Pan Sizing
Page 3
b- Cleaning The Exterior
Page 6
d- Product Unloading Page 3
c- Cleaning The Interior
Page 6
V. PRODUCT FEATURES
VIII. OTHER
a-
Casters
Page
3
a-
Service
Information
Page
6
b- Grips & Handles
Page 3
b- Spare Parts Page 6
c- Electronic Control Page 3
c- Warranty Registration
Page 6
d- On Demand Defrost
Page 3
IX. TROUBLESHOOTING GUIDE
Page 7-9
e- Condensate Evaporator Page 4
X. WIRING DIAGRAM
Page 10
f- Tray Slides Page 4
XI. WARRANTY INFORMATION
Page 11
g- Wrap Around Bumper
Page 4
XII. DOOR OPERATION
Page 12
