AutoVap15 Operating Manual | | v. 1.2
20 / 23
5)
Inconsistent Spray Pattern
ISSUE: The spray pattern at the top of the falling film doesn't seem like an even spray.
POSSIBLE CAUSE: The spray nozzle could be slightly clogged. Remove the spray nozzle and
clean it with solvent, then water, and then solvent.
6) Solvent in Vacuum Pump
ISSUE: There is a lot of solvent coming through the vacuum pump.
POSSIBLE CAUSES: You are either pulling too deep of vacuum on the system (more than 24
HG), or the chiller is not actually cooling the condenser arm (verify the chiller is working).
SECTION VI: OPERATION & SAFETY INFORMATION
Operators of the AutoVap
™ are required to follow all safety protocols and instructions. The user
and operator are responsible for any injuries to person or property while using this equipment
and are advised to follow procedures as detailed in this operating manual.
Only trained professionals with the complete understanding of the equipment- and full
understanding of the risks associated with the use of alcohol, should be operating this
equipment. The evaporating and condensing of alcohol has inherent risks. Any misuse of this
equipment can result in severe injury, including but not limited to death, disability and property
damage.
Safety Warning Definitions
·
The DANGER notice indicates and immediate hazard which, if not avoided, will result in
serious injury or death.
·
The WARNING notice indicates a hazardous situation which, if not avoided, can result in
serious injury or death.
·
The CAUTION notice indicates a potentially hazardous situation which, if not avoided, may
result in minor or moderate injury, and or damage to the equipment. Do not
proceed beyond a CAUTION notice until indicated conditions are rectified.
It is the operatorʼs sole responsibility to use the equipment in a safe manner. Operators
assume all risk associated with the use of this equipment and agrees that the equipment
is to only be used for lawful purposes.
DANGER This equipment uses high-proof alcohol. Alcohol is a flammable liquid. Improper use
may cause alcohol to discharge, resulting in an unsafe environment. Use
proper ventilation, personal protective equipment, and appropriate detectors.
DANGER Inhalation of highly concentrated alcohol vapors may affect the central nervous
system. This is characterized by nausea, headache, dizziness, unconsciousness and/ or
comma. It may cause respiratory tract irritation and a narcotic effect. Please read MSDS for
further safety instructions.
WARNING Operators must follow all precautions and safety guidelines to ensure their own
safety and the protection of property.
WARNING Always visually monitor fill levels, tanks, valves, seals and hoses for leakage. While
the system is protected with pressure relief valves, proper monitoring should be take to ensure
