46
EVENT CAUSE 24
NO MAINTENANCE
Severity Event: B
Maintenance not performed according to that prescribed in the use and maintenance manual
EFFECT - CONSEQUENCE
Damage produced to the generator
RISK - DANGER
Burst of the generator
SOLUTION - PREVENTION
- Carry out periodic preventive maintenance as defined in the use and maintenance manual
- For any repairs or replacement of components comply with that indicated in the use and maintenance manual and, however,
in cases not covered in this manual, consult the manufacturer of the generator
EVENT CAUSE 25
SYSTEM SHUTDOWN
Severity Event: B
The generator was not serviced in optimal conditions during the stop
EFFECT - CONSEQUENCE
Damage produced to the generator for effect of corrosion from oxygen in the water
Damage produced by adverse weather conditions
RISK - DANGER
Burst of the generator
SOLUTION - PREVENTION
The appliance must be preserved according to that described in the use and maintenance manual
The generator must be:
- maintained at a temperature ≥ to the minimum design temperature
- protected from rain
- stored in its internal parts, water side, as defined in the use and maintenance manual
EVENT CAUSE 26
REPLACING ACCESSORIES
Severity Event: C
The replaced accessories are not suitable for the operation to be performed
EFFECT - CONSEQUENCE
Damage produced to the generator due to the lack of control of the safety functions
RISK - DANGER
Burst of the generator
SOLUTION - PREVENTION
The replaced accessories:
- Must have the same characteristics of the original.
- Must be equipped with the relative document in compliance with Directive 97/23/EC For the calibration, refer to the use and
maintenance manual
- However, it is advisable to contact the manufacturer.
EVENT CAUSE 27
REPAIR OF THE BODY UNDER PRESSURE
Severity Event: C
The body was not repaired correctly
EFFECT - CONSEQUENCE
Damage produced to the pressurised body
RISK - DANGER
Burst of the generator
SOLUTION - PREVENTION
For repairs, it is necessary to contact the manufacturer and the Body in charge of control in operation of the steam generators
Legislation of reference: Italian Ministerial Decree of 1 December 2004 No. 329
Summary of Contents for BAHR'UNO
Page 1: ...BAHR UNO INSTRUCTIONS ON INSTALLATION USE AND MAINTENANCE ...
Page 49: ......
