Care, Maintenance and Repair
EHW-Series | Version 1.02
15
8.5 Troubleshooting
If the operating results are not satisfactory, check the
following points before systematic checks and before no-
tifying the service center:
Test the warning signal.
x
Check the contactor(s).
x
Checking the frame leakage (insula-
tion test)
x
Check function and mechanical
wear of the accelerator pedal.
x
Check the electrical system of the
drive motor.
x
Brake system: Check brake power,
replace brake disc if necessary or
adjust air gap.
x
Battery
Check battery voltage
x
Clean and grease the clamps and
check for corrosion and damage.
x
Check the battery housing for da-
mage.
x
Charger
Check the main power cable for da-
mage.
x
Check the start-up protection during
the charging process.
x
Functionality
Check the horn function.
x
Check air gap of electromagnetic
brake
x
Emergency braking test
x
Check reverse gear and regenera-
tive braking.
x
Check safety button function
x
Check steering function
x
Check the lifting and lowering func-
tion.
x
Check function of drawbar switch
x
General information
Check that all stickers are legible
and complete.
x
Check rollers, adjust or replace
height
x
Perform a test run
x
Interval
(Month)
1
3
6
12
Fault
Possible cause
Solution
T
h
e
lo
ad canno
t be
li
fted.
1. Load too high
2. Battery low
3. Malfunction of
the lifting
contactor
4. Hydraulic oil
level too low
5. Oil leakage
1. Lift only the maxi-
mum capacity indi-
cated on the name-
plate.
2. charge the battery.
3 Check and, if neces-
sary, contact custo-
mer service for re-
placement.
4 Check the hydraulic
oil and top up if
necessary.
5. repair the cylinder
seal
Summary of Contents for EWH Series
