Upright SB47JRT, Operator'S Manual

Chapter 3 – Safety

SB47JRT – 0075522

11

It is best not to transfer from the platform to another struc-

ture or from the structure to the platform, unless that is

the safest way to do the job. Judge each situation sepa-

rately taking the work environment into account. If it is

necessary to transfer from the platform to another struc-

ture the following guidelines apply:

  1. Where possible, place the platform over a roof or

walking structure to do the transfer.

  2. Transfer your anchorage from one structure to the

other before stepping across.

  3. Remember that you might be transferring to a struc-

ture where 

personal fall arrest

 is required.

  4. Use the platform entrance, do not climb over or

through the guardrails.

Do not operate the aerial platform in windy or gusty con-

ditions. Do not add anything to the aerial platform that

will increase the wind loading such as billboards, ban-

ners, flags, etc.

Never operate the aerial platform without all parts of the

guardrail system in place and the gate closed. Make sure

that all protective guards, cowlings, and doors are se-

curely fastened.

Do not exceed the platform capacity as indicated on the

platform rating placard on the platform. Do not carry loads

that extend beyond the platform guardrails without prior

written consent from UpRight.

Do not operate the aerial platform from trucks, trailers,

railway cars, floating vessels, scaffolds, or similar equip-

ment unless the application is approved in writing by

UpRight.

Do not use the aerial platform as a crane, hoist, jack, or

for any purpose other than to position personnel, tools,

and materials.

Do not climb on the guardrails or use ladders, planks, or

other devices to extend or increase the work position

from the platform.

Take care to prevent rope, electrical cords, and hoses,

etc., from becoming caught in or on the aerial platform. If

the platform or booms becomes caught on an adjacent

structure or other obstacle and is prevented from normal

motion, reverse the control to free the platform. If control

reversal does not free the platform, evacuate the platform

before attempting to free it.

Electrical System

Charge the batteries in a well-ventilated area free of flame,

sparks, or other hazards that might cause fire or explo-

sion.

Do not operate any of the aerial platform functions while

the battery charger is plugged in.

A

Warning

Batteries give off hydrogen and oxygen that can

combine explosively. Death or serious injury could

result from a chemical explosion. Do not smoke or

permit open flames or sparks when checking the

batteries.

Battery acid can damage the skin and eyes. Seri-

ous infection or reaction can result if medical treat-

ment is not given immediately. Wear face and eye

protection when working near the batteries.

Batteries contain sulfuric acid that can damage your eyes

or skin on contact. Wear a face shield, rubber gloves,

and protective clothing when working around batteries. If

acid contacts your eyes, flush immediately with clear

water and get medical attention. If acid contacts your

skin, wash off immediately with clear water.

Hydraulic System

The hydraulic system contains hoses with hydraulic fluid

under pressure.

A

Danger

Hydraulic fluid escaping under pressure can have

enough force to inject fluid into the flesh. Serious

infection or reaction will result if medical treatment

is not given immediately. In case of injury by escap-

ing hydraulic fluid, seek medical attention at once.

Do not place your hand or any part of your body in front of

escaping hydraulic fluid. Use a piece of cardboard or wood

to search for hydraulic leaks.

Engine and Fuel Handling Precautions

Refer to the engine manufacturer’s Operator’s Manual for

complete information on safe engine operation, mainte-

nance, and specifications.

A

Danger

Engine exhaust contains carbon monoxide, a poi-

sonous gas that is invisible and odorless. Breathing

engine exhaust fumes will cause death or serious

illness. Do not run the engine in an enclosed area

or indoors without adequate ventilation.

Be careful not to run the diesel fuel tank empty. Bleed

the fuel system if air enters the lines between the tank

and the injection pump.

Allow the engine to return to idle before shutting the en-

gine off.

Do not smoke or permit open flames while fueling or near

fueling operations.