Val Avionics Ltd
AP 100 Audio Panel
Installation and Operator’s Manual
Table of Contents
Pg
1
SECTION I - GENERAL INFORMATION .............................................................. 1
1.1
INTRODUCTION .............................................................................................. 1
1.2
SCOPE ................................................................................................................ 1
1.3
EQUIPMENT DESCRIPTION .......................................................................... 1
1.4
SPECIFICATIONS............................................................................................. 2
1.5
EQUIPMENT SUPPLIED.................................................................................. 3
1.6
EQUIPMENT REQUIRED BUT NOT SUPPLIED .......................................... 3
1.7
LICENSE REQUIREMENTS ............................................................................ 3
2
SECTION II - INSTALLATION................................................................................ 4
2.1
GENERAL INFORMATION ............................................................................. 4
2.1.1
Scope........................................................................................................... 4
2.2
UNPACKING AND INSPECTION ................................................................... 4
2.3
EQUIPMENT INSTALLATION PROCEDURES ............................................ 4
2.3.1
Cooling Requirements ................................................................................ 4
2.3.2
Mounting Requirements.............................................................................. 5
2.3.3
Wire Harness Fabrication ........................................................................... 5
2.3.4
Audio Panel Installation.............................................................................. 5
2.4
POST INSTALLATION CHECK ...................................................................... 6
2.4.1
Operational Check ...................................................................................... 6
2.4.2
Final Inspection........................................................................................... 6
2.5
LIMITATIONS................................................................................................... 7
3
SECTION III - OPERATION..................................................................................... 8
3.1
GENERAL INFORMATION ............................................................................. 8
3.1.1
Scope........................................................................................................... 8
3.1.2
Transmit Selection ...................................................................................... 8
3.1.3
Audio Selection........................................................................................... 8
4
SECTION IV - WARRANTY AND SERVICE....................................................... 10
4.1
WARRANTY ................................................................................................... 10
4.2
SERVICE.......................................................................................................... 11
5 Appendix A – INSTALLATION DRAWINGS AND CONNECTOR
LAYOUT .................................................................................................................. 12
6
Appendix B – WIRING DIAGRAMS...................................................................... 13
7
Appendix C – INSTRUCTIONS FOR CONTINUED AIRWORTHINESS ........... 15
7.1
MAINTENANCE INSTRUCTIONS ............................................................... 15
Table of Figures
Figure 1 Uint Controls ....................................................................................................... 8
Figure 2 Unit Controls ....................................................................................................... 9
Figure 3 Physical Dimensions ......................................................................................... 12
Figure 4 Panel Cut Out .................................................................................................... 12
P/N 0720100
i
Original Issue
October 06
