F-530.1
24
6.8 Table of service operations
Operation
During season
After season
Gearbox oil check
1x/month
yes
*
Engine oil check
before each use
**
Engine air filter check
before each use
check
Mowing knife check-fastening and intactness before each use
***
check
Knife casing intactness check
before each use
***
check
V-belt stress check
as required
check
V-belt condition check
as required
check
****
Cleaning of wheel hubs and exchange of
lubricating grease
-
yes
Cleaning of machine from impurities and
debris
after each use
yes
Tyre inflation
as required, check
1x/month
yes
*
The first exchange after 5 hours, then after 100 – 130 hours (according to oil grade);
**
Oil replacement intervals see Operating manual for engine;
***
In the case of damage (even at cutting) – cracks, bending, breakage etc. – repair
required immediately!
****
or replacement after about 200 hours.
6.9 Washing and cleaning of the machine
At cleaning and washing the machine, proceed to observe valid regulations and laws
on the protection of water courses and other water resources against pollution or
contamination with chemical substances.
Never wash the engine with a stream of water! Electric equipment might fail when
starting the engine.
All dirt, debris and plant residues should be removed from the machine after the end of
the season. Check the intactness of the working knife, grind the knife cutting edges (or
replace the knife if necessary) and conserve the knife with the conservation oil. The travel
wheels should be dismounted from the axle once in a season, cleaned and the hub inside
filled with a new filling of plastic lubricant.
The engine has to be switched off and the cable termination to the spark plug
disconnected!
Wheel disassembly, lubrication and assembly procedure:
a) Underlay the machine so that the wheels can freely turn. The machine must be secured
against spontaneous motion.
Summary of Contents for F-530.1
