V E N G E A N C E M O T O R C Y C L E S O W N E R S M A N U A L
- 69 -
Vengeance Motorcycles, Mira Loma, CA USA • 866-483-6432 • www.VengeanceMotorcycles.com
© 2004 Vengeance Performance Products, LLC All Rights Reserved • VOM 2nd Edition Rev 2.0 11/03
2,500-MILE MAINTENANCE
Change engine oil and oil filter and clean tappet screen.
Inspect transmission lubricant level and condition.
Inspect air cleaner and service as required.
Check and adjust primary belt as needed.
Check and adjust drive belt with motorcycle loaded (rider and any additional normal load).
Inspect brake pads and discs for wear.
Inspect oil lines and brake system for leaks.
Check brake fluid reservoir levels and condition. Add fluid as needed.
Check and adjust front brake lever.
Check and adjust rear brake pedal.
Check and adjust throttle and fuel enrichener operation.
Inspect fuel valve, lines, and fittings for leaks.
Check and adjust front and rear tire pressures and inspect tread and sidewall condition.
Check operation of all electrical equipment and switches.
Inspect and clean battery connections.
Inspect spark plugs and replace as needed (replacement at an additional charge).
Check stabilizer links and engine mounts.
Check and adjust engine idle speed.
Perform diagnostic test on ignition module, note readings for discussion with customer. (CA Only)
Clean debris from magnetic speed sensor on transmission.
Clean debris from neutral sensor switch.
Confirm operation and performance with road test
Complete form above, attach copy of ignition diagnostic report, and forward to:
Vengeance Motorcycles Warranty Dept. 4501 Etiwanda Avenue Mira Loma, CA 91752 Fax (909) 681-2901
(Maintain a copy of this form for your records.)
NOTE:
Proof of the 2,500-mile maintenance service is required to keep your warranty in effect
2,500-MILE MAINTENANCE SERVICE
DATE COMPLETED:__________ DEALER:______________________________
CUSTOMER:_______________________________________________________
MODEL:______________ YEAR:____________ MILEAGE:_________________
TECHNICIAN:______________________________________________________
TECH COMMENTS:_________________________________________________
__________________________________________________________________
__________________________________________________________________
__________________________________________________________________
__________________________________________________________________
ٱ
Copy of ignition diagnostic report attached (CA Only)
