18
9
IMPORTANT NOTICE
1.
The boiler can be operated only by adults familiar with this instruction manual. Do not leave unattended children near the boiler.
Interventions into the boiler design that could threaten the health of operators or housemates are forbidden.
2.
The boiler is not intended for use by persons (including children) whose physical, sensory or mental disability or lack of
experience and knowledge prevents them from using the appliance safely, if they are not supervised or were not instructed to
use the appliance by a person responsible for their safety.
3.
Children should be supervised to ensure that they do not play with the appliance.
4.
If there is a danger of development and penetration of combustible vapours or gases into the boiler room or at works with
temporarily developed fire or explosion danger (gluing the floorings, painting with flammable paints), the boiler must be put out
of operation before such works.
5.
IT IS FORBIDDEN to use flammable liquids for the boiler firing.
6.
IT IS FORBIDDEN to overheat boiler during operation.
7.
Do not put any objects made of flammable materials on the boiler and within a distance smaller than the safe distance from the
boiler.
8.
When removing the ash from the boiler, no flammable substances must be at the minimum distance of 1500 mm from the boiler.
9.
When operating the boiler at the temperature lower than 50 °C, water can condense on the boiler drum, that can lead to the so
called low-temperature corrosion, which shortens the life of the boiler drum. Therefore we recommend to operate the boiler at
50 °C and higher.
10.
In case of the storage tank use, the boiler can be again lit or the fuel can be added if the boiler is burned to the base of the fireplace and
the storage tank is empty or cooled. ATTENTION! Ignoring leads to extreme heat exchanger clogging.
11.
After the heating season, it is necessary to clean the boiler, the flues and the smoke adapter. Spread the graphite grease on the
pivots, the smoke flap mechanism and other moving parts on the boiler. The boiler room must be kept clean and dry.
12.
If the heating system is not used daily during the winter period, it is necessary to drain the water.
13.
Possible signs of corrosion on the boiler drum are not defects and do not affect the boiler function.
14.
In the system, it is necessary to install a safety valve with max. overpressure of 400 kPa (4 bar), which dimensions must
correspond to the boiler nominal output. The safety valve must be installed immediately behind the boiler. Shut-off valve must
be installed between the safety valve and the boiler. For further questions please contact our contractual installation companies
and service organizations.
15.
In case of reaction of the two-way safety valve, when there could be refilled water that does not conform to CSN 07 7401, it is
necessary to adjust water in the system so that it again conforms to this standard.
16.
When mounting, installation and operation of the appliance it is necessary to meet the standards valid in the relevant
destination country.
In case of failure to comply with these conditions, warranty repairs cannot be claimed.
10
Instructions for the product disposal after its useful life period
VIADRUS a.s. is the contract partner of the company EKO-KOM a.s. with the client number F00120649.
The packaging complies with EN 13427.
The packaging should be disposed of as follows:
-
plastic foil, cardboard package - use the special waste collection point
-
metal tightening tape - use the special waste collection point
-
wooden base is intended for single use and cannot be further used as a product. Its disposal is subject to the law 477/2001 Sb. and
185/2001 Coll. as amended.
Individual parts of the boiler should be disposed of as follows:
-
exchanger (grey cast iron) - use the special waste collection point
-
piping, shell - use the special waste collection point
-
other metal parts - use the special waste collection point
-
insulation material - through a firm dealing with waste collection and disposal
In case of loosing the use properties of the product, back collection service can be used (if applicable), in case the manufacturer
states it is waste, the waste should be disposed according to the valid legislation of the country.
