14
4.3 Requirements
•
Philips screwdriver (PH2) for removing the front.
•
Flat screwdriver (0.6x3.5) for connecting the AC leads.
•
Isolated box spanner (13 mm) for securing the terminal nuts and the fuse.
•
Two battery cables including battery terminals and cable ends.
•
Three-wire cable.
4.4 Connection of battery cables
In order to utilize the full capacity of the product, batteries with sufficient capacity and
battery cables with sufficient cross section should be used. See table.
12/3000/120
24/3000/70
48/3000/35
Recommended battery capacity (Ah)
400–1200
200–700
100–400
Recommended cross section (mm
2
)
0 – 5 m
90
50
35
5 – 10 m
120
90
70
Remark: Internal resistance is the important factor when working with low capacity
batteries. Please consult your supplier or the relevant sections of our book “Energy
Unlimited”, downloadable from our website.
Procedure
Proceed as follows to connect the battery cables:
Use an insulated box spanner in order to avoid shorting the battery.
Avoid shorting the battery cables.
•
Undo the four screws at the front of the enclosure and remove the front panel.
•
Connect the battery cables: the + (red) on the right and the - (black) on the left,
see Appendix
0
.
•
Reverse polarity connection (+ to – and – to +) will cause the “reversed polarity”
LED next to the terminal nuts to light up.
•
Disconnect the cables and reconnect them correctly if the “reversed polarity" LED
is illuminated.
•
Tighten the connections after positioning the fastening items supplied with the
product.
•
Position the Mega fuse from the connection bag in position F4 and secure it,
using the fastening items supplied with the product.
•
Secure the nuts tightly in order to reduce the contact resistance as much as
possible.
Summary of Contents for Phoenix MultiPlus 24/3000/70
