7
1966-67 CHEVELLE
WITH AC
904466 REV A 5/8/09 , 1966-67 CHEVELLE w AC EVAP INSTR PG 7 OF 22
REMOVE GLOVE BOX DOOR (RETAIN) AND GLOVE BOX (DISCARD).
DISCONNECT ALL WIRE AND CABLES FROM CONTROL PANEL AND RADIO.
ALL HOSE AND DUCTING FROM O.E.M LOUVERS, SEE FIGURE 2 BELOW
O.E.M DEFROST DUCT ASSEMBLY, SEE FIGURE 3 BELOW.
O.E.M AC/ HEATER ASM SEE FIGURE 3 BELOW
PASSENGER SIDE KICK PANEL/ FRESH AIR DOOR ASM AS SHOWN IN FIGURE 2a
PASSENGER COMPARTMENT
CONDENSER ASSEMBLY & INSTALLATION
REFER TO SEPARATE INSTRUCTIONS INCLUDED WITH THE CONDENSER KIT TO INSTALL THE
CONDENSER.
BINARY SWITCH INSTALLATION (REFER TO CONDENSER INSTRUCTIONS)
REFER TO SEPARATE INSTRUCTIONS INCLUDED WITH THE BRACKET KIT TO INSTALL THE
COMPRESSOR BRACKET.
COMPRESSOR & BRACKETS
REMOVE THE FOLLOWING:
REMOVAL OF DASHBOARD REQUIRED TO INSTALL THE EVAPORATOR. VINTAGE AIR
RECOMMENDS THAT YOU UTILIZE THE FACTORY SERVICE MANUAL WHEN YOU DISASSEMBLE
AND REASSEMBLE THE DASHBOARD.
NOTE:
DEFROST DUCT
ASM
OEM A/C HEATER ASM
CONTROL
PANEL
AC/HEATER ASSEMBLY
GLOVE BOX
& RELATED DUCTING
FIGURE 2
FIGURE 2 a
FIGURE 3
FRESH AIR
DOOR ASM
