maIntenance and warr ant y
32
VMI CONVERSION SCHEdULEd MAINtENANCE PLAN
NOTE:
If the VMI Conversion Stow/Deploy front dash button blinks red 3 times at the end of a cycle, this
means your 750-cycle preventative maintenance service is due. See page 8 for complete lighting indicators.
Expenses associated with the above scheduled maintenance are not covered under the VMI limited warranty program.
Must be Performed Every
6 Months or 750 Ramp Cycles
by an Authorized VMI dealer
Power Door System
Ramp System
· Check proper door operation. Adjust door and/or limit switches as
necessary.
· Inspect and clean driver side and passenger side lower sliding
door tracks and remove any debris from the track to ensure
smooth door operation.
· Check door cable for unusual wear or fraying. Check lower, middle
and upper rollers for wear or damage; replace as required.
· Inspect and replace normal wear items as required.
· Remove floor plate and inspect ramp operation.
· Inspect ramp mechanism for loose fittings, alignment, and
abnormal wear.
· Clean and lubricate ramp drive mechanisms as needed.
· Inspect and clean ramp sensors and limit switches.
· Check SURE DEPLOY® system operation and battery.
· Inspect and replace normal wear items as required.
Undercarriage Inspection
· Check undercarriage for component damage
· Check undercarriage for rust or corrosion and repair as needed
· Check electrical connection at battery for corrosion
· Check main ground near VMI control module
· Inspect and replace normal wear items
PowerKneel® System
· Inspect entire PowerKneel® mechanism for loose fittings,
alignment, and abnormal wear
· Clean and lubricate kneel drive mechanisms
· Inspect kneel switches
· Verify PowerKneel® back up operation is functional
Must be Performed Every
12 Months or 1,500 Ramp Cycles
by an Authorized VMI dealer
Summary of Contents for Northstar Power Conversion
