P34AL-15 & P34ALOF-15 Service Manual
Options and Accessories
9/22/05
10-10
MACHINE FAULTS (CONT.)
Compressor Overload:
The interface will display the message shown below if the compressor
motor safety overload switch opens. The machine will stop immediately. The compressor overload
will reset automatically after the compressor has time to cool off.
B=SILENCE ALARM
A=RESTART
FAULT:COMP OL
WAITING
B=SILENCE ALARM
A=RESTART
FAULT:COMP OL
COMP OK
When the compressor overload resets the interface will display “COMP OK”. It will be necessary to
press “A” on the operator interface to restart the machine.
Long or Short Cycle Safety:
The interface will display the messages shown below if there is a
long or short cycle condition. The machine will stop upon indication of either of these conditions.
A long cycle is defined as a freeze cycle that extends for a duration of one hour. This could be
caused by an open drain valve, leaking hot gas valve or defective compressor. The short cycle
safety will stop the machine after three consecutive freeze cycles of less than five minutes duration.
Short cycling can be caused by a restriction in the liquid line, inadequate make-up or circulating
water, or a defective freezer pressure switch.
B=SILENCE ALARM
A=RESTART
FAULT:LONG CYC
FREEZE CYCLE
B=SILENCE ALARM
A=RESTART
FAULT:SHORT CYC
3 IN A ROW
It will be necessary to press “A” on the operator interface to restart the machine.
! CAUTION !
When the operator interface indicates a fault, something has gone wrong. Every effort
should be made to discover the reason for the fault. Do not simply reset the fault and resume
operation. The underlying cause will likely reoccur, interrupt ice supply and potentially
damage equipment.
! CAUTION !
Summary of Contents for P-34AL-15
