P34AL-15 & P34ALOF-15 Service Manual
INSTALLING YOUR TUBE-ICE MACHINE
9/22/05
3-9
cycle is 50% (75% is preferred). If the compressor cannot be unloaded then a hot gas bypass to the
suction line must be installed. See Figures 3-11 through 3-14.
Cooling Tower (optional).
When selecting a cooling tower, careful attention must be given to
operating wet bulb conditions. It is advisable to check with your local cooling tower distributor for
their recommendations based on actual operating conditions in your area. An average wet bulb of
78
°
F is typical in the U.S., but many localities have designed wet bulbs as low as 72
°
F or as high as
82
°
F.
The cooling tower water pump must be capable of delivering the required volume of water through
the condenser. Due to cooling tower location and pressure drop through water lines and regulating
valves, the water pump must be sized for each installation. Table 3-3 shows the total heat rejection,
in 1000 BTU’s per hour for the P34AL-15 and P34ALOF-15 at different suction temperatures. The
water piping for the cooling tower and the installation of the pump must be in accordance with the
manufacturer’s instructions. Caution must be used to prevent the condenser water pump from losing
prime during off cycles.
Proper water treatment for the prevention of mineral and foreign matter accumulation in the
condenser or cooling tower is recommended. A water analysis should be obtained to determine the
proper chemicals to use. The use of a 40 mesh strainer in the condenser water supply line is also
recommended.
P34AL-15 - Cylinder
P34ALOF-15 - Cylinder
Suction
Temperature
°
F /
°
C
1”
Tube
1 1/4”
Tube
1 1/2”
Tube
1”
Tube
1 1/4”
Tube
1 1/2”
Tube
21.4 /-6.0
1619
1326
995
1704
1395
1032
16.6 /-8.5
2067
1728
1309
2174
1818
1357
11.3 /-11.5
2677
2302
1764
2815
2422
1829
5.5 /-15.7
3142
2757
2132
3303
2900
2210
-1.0 /-18.3
3657
3280
2562
3845
3449
2655
P34AL-15 - Crushed
P34ALOF-15 - Crushed
21.4 /-6.0
1619
1841
1968
1704
1936
2039
16.6 /-8.5
2067
2325
2425
2174
2445
2511
11.3 /-11.5
2677
2972
3008
2815
3124
3115
5.5 /-15.7
3142
3455
3426
3303
3631
3548
-1.0 / -18.3
3657
3983
3871
3845
4186
4007
Total Heat Rejection is based on pulldown of 105
°
F SDT and are nominal values based on open drive
reciprocating compressor.
Consult factory for condenser sizing if desired.
TABLE 3-3
Total Heat Rejection (MBH)
The condenser water pump should be sized on GPM required for condenser at 80 ft. total discharge
head for a typical installation. However, due to cooling tower location and pressure drop through
water lines, the water pump should be sized for each installation.
Summary of Contents for P-34AL-15
